Documente Academic
Documente Profesional
Documente Cultură
The elevation of the device is designed 3 feet (36 in.) above the ground aligned to the
monitoring well pipe opening so that the water suction will be easier for the device.
Water pump is mounted at the top segment of the device to be able for the water in the
A 100mL glass cylinder is connected to the pipe that is used for the water sample
following the Department of Health National Drinking Water Standard in the Philippines. The
device is programmed so that once the glass cylinder accumulated a 100mL water sample, it will
Another pipe is connected at the bottom part of the glass cylinder leading the water to
flow to a Flow Cell. Flow Cell is a very thin tube that water cannot enter normally for sampling.
A water pump is connected below the pipe to have a necessary force needed for the water to
The connected water pump will only operate once the previous water pump stop its
The Flow Cell is designed tilted 45 degrees from the vertical connected to a pipe so that
the UV LED and the Photodiode will be complementary with each other performing the best
accuracy.
UV LED emitting UVC is placed 0.02m (0.7 in) close above the Flow Cell to be able for
the present E. coli to be exposed fully with the UV light, the closer the UV LED the better the
detection.
The Photodiode facing the flow cell and in 90 degrees with the UV LED will be the
responsible in capturing the desired wavelength for the E. coli count then sending the
The Arduino with GSM Module is placed near the position of the antenna so that less