Documente Academic
Documente Profesional
Documente Cultură
SET-A
Question Paper
(2) The Atterbergs limits of a particular soil are reported as follows- liquid limit 60%, plastic
limit 50%, shrinkage limit 40%. The plasticity index of above soil will be :
(a) 40% (b) 30%
(c) 10 % (d) 20%
(4) Two weights of 100 N and 200 N are suspended at the ends of a lever 300 mm long. The
position of fulcrum will be :
(a) 100 mm from 100 N weight b) 200 mm from 200 N weight
(c) 100 mm from 200 N weight d) 200 mm from 100 N weight
(5) The bending moment diagram for a cantilever beam carrying concentrated load at the free
end will be :
(a) Triangle (b) Rectangle
(c) Parabola (d) Square
1
Roll No . Signature of candidate..
SET-A
(9) The instrument used to find the area of an irregular figure is known as:
(a) Ceylon Ghat Tracer (b) Abney Level
(c) Planimeter (d) Box Sextant
(10)If the fore bearing of a line is N20 W, its back bearing in Whole Circle Bearing will be :
(11)Number of Metric Size bricks required to construct a wall 3.0 m long, 2.0 high and half brick
thick will be :
(a) 150 (b) 300
(c) 600 (d) 1200
(13)If the difference in elevation of an edge of the pavement (9m wide) and its crown is 15
cm, then the camber in the pavement will be :
(a) 1 in 15 (b) 1 in 30
(c) 1 in 45 (d) 1 in 60
(15)R.L. of known points is 100 m back sight and fore sight reading are 1.2 m and 1.3 m
respectively find R.L. of unknown point :
(a) 99.90 meter (b) 101.2 meter
(c) 101.3 meter (d) 100.0 meter
2
Roll No . Signature of candidate..
SET-A
(18)No. of Standard Metric size bricks required for one cubic meter of brick masonry is :
(19)The height of the building is 3 m and riser of step is 15 cm. then number of treads will be :
(a) 18 (b) 19
(c) 20 (d) 21
(21)If commercial vehicle per day (CVPD) is 45 to 150 which curve you will use for flexible
pavement design :
(a) A (b) B
(c) C (d) D
(22)Which of the following coat is provided for strong binding between old layer of bituminous
surface and new one :
(a) Tack Coat (b) Primer Coat
(c) Seal Coat (d) Surface Dressing
(24)In construction of single story building in a black cotton soil area generally following type of
foundation is used :
(a) Spread Footing Foundation (b) Column Footing Foundation
(c) Pile Footing Foundation (d) Strep Footing Foundation
(25)To Calculate average rainfall the record of following years is taken in consideration :
(a) 20 years (b) 35 years
(c) 50 years (d) 100 years
3
Roll No . Signature of candidate..
SET-A
(28)In a irrigation tank the capacity of water between FTL and LSL is known as :
(a) Live Storage (b) Dead Storage
(c) Flood Storage (d) Gross Storage
(29)Contour is known as :
(a) Line joining the same weight (b) The line joining the same
distance
(c) Line joining the same elevations (d) None of these
(36)For supplying water to Rabi Crop, Kharif Crop and Sugar cane, the canal is designed for
a capacity equal to :
(a) Rabi or Kharif Crop (b) Rabi + Kharif or Sugar Cane
(c) Sugar Cane + Rabi or Kharif (d) Rabi or Kharif or Sugar Cane
4
Roll No . Signature of candidate..
SET-A
(37)The valve which allowed the water to flow in one direction and prevents it from flowing
back is known as :
(a) Check Valve (b) Air Valve
(c) Sluice Valve (d) Drain Valve
(38)For a Grit Chamber the recommended velocity of flow is 0.2 m/s and detention period
is 2 minutes, the length of the Grit Chamber will be :
(a) 10 m. (b) 20 m.
(c) 24 m. (d) 40 m.
(39)Quantity of mortar required for 12 mm thick cement plastering per 100 sqm is :
(40)A paneled door of size 1.1 m x 2.0 m. is to be painted both sides. The quantity of painting
work will be :
(a) 2.2 m2 (b) 4.4 m2
(c) 4.95 m2 (d) 4.90 m2
5
Roll No . Signature of candidate..
SET-A
(49)In Common Wealth Games 2010 New Delhi, India won first Gold Medal in :
(a) Archery (b) Shooting
(c) Weight Lifting (d) Fencing
(50)Which denomination of Indian Rupee does not bear the signature of Governor of RBI
(a) Rs. 1000 (b) Rs. 100
(c) Rs. 1 (d) Rs. 500
(55)The volume of Coarse aggregate required for making one cubic meter 1:2:4 Concrete:
(a) 0.95 cum. (b) 0.75 cum.
(c) 0.85 cum. (d) 1.0 cum.
6
Roll No . Signature of candidate..
SET-A
(56)In a simply supported beam of spam 5.0 meter with uniformly distributed load of 600 kg.
per M, shear force at the end will be :
(a) 1500 kg. (b) 300 kg.
(c) 600 kg. (d) 3000 kg.
(57)In a simply supported beam of 4.0 meter span loaded with 300 kg/M uniformly
distributed load the maximum bending moment at center will be:
(a) 300 kg. m. (b) Zero
(c) 1200 kg. m. (d) 600 kg. m.
(58)The initial and final setting time for ordinary port land cement as per IS specification is:
(a) 10 min & 30 min (b) 30 min & 10 hour
(c) 60 min & 10 hour (d) 10 hour & 30 hour
(59)The most commonly used retarder in cement to increase initial setting time is :
(a) Gypsum (b) Calcium Chloride
(c) Calcium Carbonate (d) None of the above
(60)If a concrete cube of standard size gets crushed at 45 T. load the crushing strength of
concrete will be :
(a) 100 kg/ cm2 (b) 150 kg/ cm2
(c) 200 kg/ cm2 (d) 300 kg/ cm2
(61)For normal mix of M-20 (by volume) the ratio of cement: send: metal is :
(a) 1:3:6 (b) 1:2:4
(c) 1:1.5:3 (d) 1:4:8
(63)Thickness of sub grade in a road as per MORTH and specification for rural road
(MoRD):
(a) 60 cm, 60 cm (b) 60 cm, 30 cm
(c) 30 cm, 30cm (d) 30 cm, 60 cm
(64)In a standard stack measuring 1.5 m X 1.5 m X 0.5 m size the quantity of moorum and
metal measured as :
(a) 1 cum. & 0.9 cum (b) 1.125 cum & 1 cum
(c) 0.9 cum & 1.0 cum (d) 1.125 cum & 0.9 cum
7
Roll No . Signature of candidate..
SET-A
(66)In a concrete mix of M-30, the 7 days crushing strength of standard cube will be :
(a) 210 kg per Sq cm. (b) 225 kg per Sq cm.
(c) 150 kg per Sq cm. (d) 300 kg per Sq cm.
(67) Auto Cad is a :
(a) Soft Ware (b) Hard Ware
(c) Operating System (d) Input Device
(72) Which of the following test is not performed for WBM aggregate :
(a) AIV (b) Gradation
(c) Flakiness/ Elongation Index (d) Crushing Strength
8
Roll No . Signature of candidate..
SET-A
(76) In an aqueduct:
(a) River flows below aqueduct (b) Canal flows below aqueduct
(c) River and Canal flow together (d) River and Canal flow separately
(83) 1 GB is equal to :
(a) 1024 MB (b) 1000 MB
(c) 1020 MB (d) None of the above
9
Roll No . Signature of candidate..
SET-A
(87) For making a presentation for Meeting which tool is mostly used :
(a) Excel (b) Power Point
(c) Access (d) Media Player
(89) Which one of the following is not essential for Internet Connection:
(a) Computer (b) Modem
(c) Telephone Connection (d) Printer
(92) Higher value Contour in inner circles and lower value contour on outer circles denotes:
(a) Valley (b) Mountain
(c) Plain area (d) None of the above
(93) Quantity of earth work in 100 meter long trench having bottom width 0.4 meter, top
width 0.6 meter and depth 0.3 meter, soil classification 60 % hard soil and 40 % soft rock
:
(a) 9 cum hard soil, 6 cum soft rock (b) 6 cum hard soil, 9 cum soft rock
(c) 90 cum hard soil, 60 cum soft rock (d) 60 cum hard soil, 90 cum soft rock
(94) An unsaturated sample of soil has a volume of 100 cu cm and weight 190 gms. After
drying in an oven for 24 hours, the weight is reduced to 160 gms. Water content of the
soil is :
(a) 0.188 (b) 0.288
(c) 0.388 (d) 0.488
10
Roll No . Signature of candidate..
SET-A
(95) Quantity of Metal required for 10 m long wall of 0.3 meter top width and 0.5 meter
bottom width of 1 meter height to be constructed with 1:2:4 nominal mix :
(a) 3.4 cum (b) 4 cum
(c) 4.4 cum (d) 40 cum
(96) Quantity of Puddle earth required for 100 meter long puddle trench of size 0.6 meter
bottom width, 0.9 meter top width, 1 meter depth and 30 cm puddle core :
(a) 102 cum (b) 100 cum
(c) 120 cum (d) 75 cum
(97) A soil has a bulk density of 2.4 gm/cu. cm. and water content 20%, the dry density of the
sample will be :
(a) 0.5 gm/c.c. (b) 2 gm/c.c.
(c) 2.2 gm/c.c. (d) 1.2 gm/c.c.
11