Documente Academic
Documente Profesional
Documente Cultură
False
Question 2
Increase in shear plane angle in machining reduces the cutting force.
Correct
False
False
Question 4
o
Bending the edges of sheet metals to 90 is called hemming
Correct
Select one:
Mark 1.00 out of
1.00 True
False
False
False
False
Question 8 Hot tears in the casting can be due to poor collapsibility of mould
Incorrect
Select one:
Mark 0.00 out of
1.00 True
False
Question 9
Drawability of the material is determined by normal anisotropy.
Correct
False
b. investment casting
c. shell moulding
Question 11 Velocity of the chip is always greater than the cutting velocity
Incorrect
Select one:
Mark 0.00 out of
1.00 True
False
Question 12
In orthogonal machining, cutting edge is perpendicular to cutting force.
Correct
False
Select one:
True
False
Question 14 Several operations on the same strip performed in one stroke at one station
Correct with a compound dies
False
Question 15 Formation of small new grains from large grains is called recovery
Incorrect
Select one:
Mark 0.00 out of
1.00 True
False
False
False
Question 18 Formability of material in hydrostatic extrusion is better than the direct and
Correct indirect extrusion.
False
False
Question 20
Chip thickness ratio is always less than one.
Correct
False