TABLE 45
Maximum Nozzle Limitations
No.of | Quant. Tora ax, Total
‘of | Numberot | Area | Nozzle Area
unit | Discharge | Nozzles | Nozzles | Coverage | Coverage | “D™
Ports Used | Per Per Per Pe
wr) DP. Unit Nozale unit__| ey
T T T Ber | 420
T 2 Bore | 335
3Ly 2
2 7 ser? | ala
T 2 aere | 335
6a I2Lb, 2
2 7 Be? | 22
Whore "D” = Maximum straight ine distance from the conterline of the nozzle to the farthest
corner of the area protected by a given nozzle,
Figure 4-2 describes the individual nazzle coverage and maximum dimension “D" for each unit
configuration.
FIGURE 4.2
INDIVIDUAL NOZZLE COVERAGE
ULEX S323/FMRC File 5612 PIN: 800022 UL Rev, 04/23/08
2Example: Determine if 2-nozzle unit meets the nozzle area coverage limits to protect a 4 Ft wide x 9
Ftlong x 8 Ft high enclosure shown in Fig 4-3.
FIG 4.3
Procedure:
Into two imaginary areas 4 wide x 4.5" long.
3nce *D" as shown in FIG 4-3
=3.01Ft
¢. This arrangomant is acceptable fr a two nozzle configuration since:
+The caleulated dimension *D” (3.01 Ft) is less than the 3.36 Ft maximum shown in
TABLE 4-5 for a two nozzle co
does not exceed the 18 Ft?
tal area coverage per unit (4x9! = 36 FY’) does not exceed the 36 Ft? shown in
45,
+The 8 Ft enclosure height is less than the 12 Ft mit
49.3 Discharge Tubing & Fitting Specifications
{Al Frotrace ILP Units shal uso copper tubing forthe FM-200 distribution system. The following
tubing and fitings shall be used.
‘Tubing Specifications:
Material: Soft Annealed Copper:
AS B-280, for
Size: 5/16" OD x .03
Note: The AS B-2%
for use inthe Firetrace FM-20¢
ULEX S329/FMRC File 5612 PIN: 800022 ULRev 6, 04/23/08
2