Documente Academic
Documente Profesional
Documente Cultură
REGISTRATION
HINT:
f. Enter the menu items in this order: Powertrain / ECT / Utility / A/T Code Registration.
g. Select "Set Compensation Code".
h. Register the compensation code.
1. Press "Input".
2. Manually input the transaxle compensation code. The code is a 60-digit alphanumeric value
printed on the QR label. After inputting the code, press "OK".
i. Check that the compensation code displayed on the screen is correct by comparing it with the 60-
digit alphanumeric value on the QR label.
HINT:
If the registration process fails, the compensation code may be incorrect. Check the
l
compensation code again.
l If the attempted compensation code is correct, a problem with the wire harness or a bad
connection with the DLC3 may cause a registration failure. Check the wire harness and the
DLC3 connection. If no problem is found, the TCM may be malfunctioning. Check the TCM
and repeat this operation.
k. Press "EXIT".
2. TRANSFER TRANSAXLE COMPENSATION CODE
HINT:
The following operation is available for use with TCMs that can transmit the registered transaxle
compensation code to Techstream.
Wednesday, May 31, 2017 4:31:10 PM Page 2 2011 Mitchell Repair Information Company, LLC.
2008 Toyota Camry
2008 TRANSMISSION U660E Automatic Transaxle - Camry
HINT:
HINT:
Press "Overwrite".
NOTE: Do not use the code specified on the transaxle QR label even if
the transmission compensation code cannot be read using
Techstream. The code printed on an in-service transaxle may
not match its current characteristics. Replace the TCM with a
new one and perform a road test to allow the TCM to learn.
5. Press "EXIT".
6. Turn the ignition switch off.
f. Replace the TCM.
g. Set the transaxle compensation code.
1. Turn the ignition switch on (IG).
2. Turn the tester on.
3. Enter the menu items in this order: Powertrain / ECT / Utility / A/T Code Registration.
4. Select "Set Compensation Code".
5. Press "Open".
6. Press "Open" again to proceed.
7. Press "Exit".
Wednesday, May 31, 2017 4:31:10 PM Page 3 2011 Mitchell Repair Information Company, LLC.