Documente Academic
Documente Profesional
Documente Cultură
Result Processing
(Cylinder Impact)
16.0 Release
Introduction to
ANSYS Explicit STR
2015 ANSYS, Inc. April 15, 2015 1
Workshop Goal and Procedure
Goal:
Process results from the previously constructed cylinder impact test model showing
multiple Workbench post-processing features.
Procedure:
Duplicate the existing Explicit Dynamics (ANSYS) Analysis System Project
Demonstrate the results processing features:
Adjust the legend controls
Show the capped surface displays
Create a section plane
Make a vector plot
Create a chart
Show graphics in multiple views
RMB SC
DC RMB
DC
1st point
Slide square to
right with
LMB
Note: For section views, Undeformed shows the Hidden Deformed geometry as
opposed to the true Undeformed geometry.
2015 ANSYS, Inc. April 15, 2015 11
Step 4 Create a Section Plane
4.i Now uncheck the Section Plane 1 display.
RMB
5.g Use the above settings on the Vector Display Toolbar that appears
2015 ANSYS, Inc. April 15, 2015 15
Step 5 Make a Vector Plot
5.h Switch the View to 5.i Use the settings below on the Vector Display
Wireframe and switch Toolbar to investigate their effects
the display mode to No
WireFrame.
RMB
RMB
7.b Highlight
each of the
viewports, in
turn, and
define the
graphics
settings for
each one. A
few possible
views are
shown to the
left.