Documente Academic
Documente Profesional
Documente Cultură
STANDARD
ICS: 43.040.10
Descriptors: road vehicles, environmental conditions, testing, electrical and electronic, equipment,
components, system, general
Copyright 2011
DEPARTMENT OF STANDARDS MALAYSIA
DEVELOPMENT OF MALAYSIAN STANDARDS
Contents
Page
Committee representation.................................................................................................................................ii
National foreword...............................................................................................................................................iii
Foreword.............................................................................................................................................................iv
Introduction.........................................................................................................................................................v
1 Scope .................................................................................................................................................... 1
2 Normative references ........................................................................................................................... 1
3 Terms and definitions........................................................................................................................... 1
4 Classification by mounting location ................................................................................................... 3
4.1 Engine compartment ............................................................................................................................ 3
4.2 Passenger compartment ...................................................................................................................... 3
4.3 Luggage compartment/load compartment......................................................................................... 3
4.4 Mounting on the exterior/in cavities ................................................................................................... 3
4.5 Other mounting locations .................................................................................................................... 4
5 Operating modes .................................................................................................................................. 4
5.1 Operating mode 1 ................................................................................................................................. 4
5.2 Operating mode 2 ................................................................................................................................. 4
5.3 Operating mode 3 ................................................................................................................................. 4
6 Functional status classification .......................................................................................................... 4
6.1 General................................................................................................................................................... 4
6.2 Class A................................................................................................................................................... 5
6.3 Class B ................................................................................................................................................... 5
6.4 Class C ................................................................................................................................................... 5
6.5 Class D ................................................................................................................................................... 5
6.6 Class E ................................................................................................................................................... 5
7 Tests and requirements ....................................................................................................................... 5
7.1 General................................................................................................................................................... 5
7.2 General test conditions ........................................................................................................................ 5
7.3 Test sequence ....................................................................................................................................... 6
8 Designation ........................................................................................................................................... 6
8.1 Coding.................................................................................................................................................... 6
8.2 Use of Code Z as agreed .................................................................................................................. 7
Annex A (informative) Example for a test sequence plan .............................................................................. 8
Annex B (informative) Example of life test/statement of reliability............................................................... 9
Committee representation
The Industry Standards Committee on Road Vehicles (ISC L) under whose authority this Malaysian Standard was
adopted, comprises representatives from the following organisations:
The Technical Committee on Electrical and Electronic Equipment which recommended the adoption of the ISO
Standard as Malaysian Standard consists of representatives from the following organisations:
Co-opted members:
NATIONAL FOREWORD
The adoption of the ISO Standard as a Malaysian Standard was recommended by the
Technical Committee on Electrical and Electronic Equipment under the authority of the
Industry Standards Committee on Road Vehicles.
This Malaysian Standard is identical with ISO 16750-1:2006, Road vehicles - Environmental
conditions and testing for electrical and electronic equipment - Part 1: General, published by
the International Organization for Standardization (ISO). However, for the purposes of this
Malaysian Standard, the following apply:
a) in the source text, "this International Standard" should read "this Malaysian Standard";
and
b) the comma which is used as a decimal sign (if any), to read as a point.
MS ISO 16750 consists of the following parts, under the general title Road vehicles -
Environmental conditions and testing for electrical and electronic equipment:
Part 1: General
Compliance with a Malaysian Standard does not of itself confer immunity from legal
obligations.
NOTE. IDT on the front cover indicates an identical standard i.e. a standard where the technical content, structure,
and wording (or is an identical translation) of a Malaysian Standard is exactly the same as in an International
Standard or is identical in technical content and structure although it may contain the minimal editorial changes
specified in clause 4.2 of ISO/IEC Guide 21-1.