Documente Academic
Documente Profesional
Documente Cultură
Required material:
Handout material from classroom
Instructions:
1. Enter into CDI control unit (N3/9) and then Control Unit Adaptation. Under
version coding how many items are displayed after the note screen? ______
2. Under SCN coding, read coding for this vehicle and record.
_____________________________________________________________
_____________________________________________________ _
4. Now looking at injector #2 on the vehicle, does the coding match what you
5. If vehicle had a new injector installed, after entering the proper injector code,
you would then select Injector injection quantity adjustment from same
6. Back out of Adjustment of injector injection quantities and enter into reset
quantity mean value adaptation data. After replacing what components does
a. _______________________________________________________
b. _______________________________________________________
c. _______________________________________________________
7. Continue into reset quantity mean value adaptation data. Notice the system
1. Go to smooth running in the actual value section. What other test requirement is
________________________________________________________________
2. On the actual value screen, what is the limit for the quantity correction value of a
cylinder? ________________________________________________________
values? _________________________________________________________
6. Next unplug injector #2. Does the value go over 5mm3/HUB? YES NO
7. Plug back in injector #2. Check for fault codes. Did unplugging the injector leave
If you have noticed any parts that need to be replaced on this vehicle, please inform
your instructor now.