Documente Academic
Documente Profesional
Documente Cultură
Geotextiles
Rod Smith[11]
United Kingdom
Separator
Container
Reinforcement
Filter
Mulching
Fences
Tension Membrane
Cushion
Road-Asphalt Overlay
Road Sub-Base
The use of industrial fabrics in the civil engineering industry was identified as the
new, and potentially very large, market in which to sell synthetic textiles. Figure 2
shows some of these applications for textiles. Originally the main use was as a
filter between soils of different particle sizes and the general name used for
textiles in civil engineering was "filter fabric". Only later did the term "geotextile"
gain usage[12]. The required properties and function of the geotextile is related to
its application. The Geotextiles Manual[13] identifies the relative importance of its
function as shown in Figure 3.
Figure 3: Importance of geotextile functions and properties related to
applications
The main uses of geotextiles are as separators and in asphalt overlays followed
by drainage with erosion control accounting for about 8 percent of all uses[14] in
1997. (Figure 4) More recently other authors[15] have estimated erosion control
applications as using some 170 million sq.m of geotextiles which would equate to
about 12 percent of total usage in 2000.
There are three possible areas to explore for sisal geotextiles:
the existing applications of natural fibre geotextiles
applications where currently synthetics are used
new fields for geotextile use.
The last of these will probably be the most difficult unless the manufacturers
identify a unique property of sisal which is not possessed by other geotextiles. It
will be useful to explore the second area to review if sisal can compete with
synthetics, but many of these applications are for medium or long term periods.
However the first area is where sisal manufacturers are likely to begin to make
headway into the existing market for natural fibre geotextiles. Here the
characteristics of sisal will be pitted against those of coir and jute and the sisal
geotextile manufacturers against a long established and functioning supply
system of other natural fibre geotextiles.
2 MAIN USES OF NATURAL FIBRE GEOTEXTILES
As a pointer to the potential of sisal it may be helpful to examine the requirements
made of the geotextile in the current area of use of other natural fibre geotextiles.
There are many requirements for the applications shown in Table 1, but strength,
low extension in service and durability are usually of prime importance.
Figure 4: Use of geotextiles by application
Designers of soil erosion control systems usually only need the geotextile to
provide ground protection and to create a micro-climate for the seedlings until
vegetation is established which is often for one or two growing seasons. Thus the
durability of even low weight jute geotextiles is adequate in most cases and sisal
would be expected to outlast jute. In cases of river banks or extreme applications
where plant growth is expected to take longer then sisal would probably have an
advantage.
The requirement of a mulch is to provide tight ground cover to suppress weed
growth and to enhance the crop by providing a beneficial micro-climate around
the plant. Thus there is generally no need for longevity and strength is needed
only for reasons of handle-ability. Here the sisal fabric would need to be tight and
lightweight.
Table 1: Requirements of geotextiles in selected applications
Required Characteristics
Strength Low Extension Durability
Erosion Control to
Agro-mulching
Un-paved Roads
KEY: Important: (); Less important (); Not important ().
As seen in Figure 4 above, a large tonnage of geotextiles is used as separators
between the road sub-base and the soil formation below and as reinforcement
below sub-base layers of non-paved roads and temporary roads. The design of
many such roads will probably require a geotextile of medium durability or better.
This application demands a geotextile of strong tensile capacity which exhibits
only a small extension at working loads in order that the geotextile shares some
of the load imposed by the traffic and to assist the granular sub-base to remain
stable with minimum rutting.
Let us examine each of these applications in turn.
2.1 Soil erosion control
Soil erosion has been occurring for some 450 million years, since the first land
plants formed the first soil although it only became a serious problem in recent
centuries because of the accelerated erosion. Erosion is often the result of
human activity, such as unsuitable cultivation practices and forestry exploitation
which leaves the land vulnerable during times of heavy rainfall and high winds.
Often slopes are formed either by cuttings or embankment fills when roads or
railways are built or when land is developed. For an economical earthwork and to
reduce the area of un-productive land, steep slope angles are preferred, but, the
steeper the slope the greater the risk of soil erosion. Soil erosion by water and
wind is responsible for about 56 percent and 28 percent respectively of world-
wide land degradation.[16] The US Army Corp of Engineers has estimated that in
the USA alone the damage caused by soil erosion costs at least $200 million
annually.
A soil erosion nuisance can become a serious landslide problem causing damage
to property and loss of life. The solution is the provision of an erosion control
systems such as shown in Figure 5. Figure 5a shows a geotextile laid out over a
pre-seeded slope and Figure 5b shows the completed work with the green shoots
just starting to grow through the geotextile. Vegetation is well established in
Figure 5c.
The ground cover used is not usually a geotextile but a lightweight plastic film but
some geotextiles, both synthetic and natural fibre, are used. The crop is planted
in holes cut through the sheet. The film sheet is usually discarded at the time of
harvesting the crop and thus there is no need for long durability.
It is desirable to use a geotextile with a large percentage of cover in order to
block out the light and hence deprive weeds of growth potential and thus non-
woven fabrics would be the ideal choice. A geotextile is also more effective than
a thin film as a temperature insulator and studies have shown that they benefit
the crop by reducing high summer peak temperatures and reducing the risk of
low night time temperatures.
2.3 Un-paved roads
The principal method is to lay a geotextile on the road formation before the
granular sub-base is laid. If the geotextile is strong enough and does not extend
too much it contributes to supporting the traffic loads by various actions[17] as
illustrated in Figure 6.
Accurate figures are not easy to obtain in some sectors of the market but Figure
9 shows a best estimate for the various market segments.
About half (750 M sq.m) of the total are applications where sisal geotextiles could
possibly be considered for use depending on the durability of the fibres. The
established market for erosion control geotextiles which does not require product
longevity is 170 M sq.m and half of this is provided for by natural fibre geotextiles.
While most agro-mulch sheets are currently not geotextiles they amount to an
enormous market of some 2600 M sq.m, nearly twice that of all geotextile
applications[20].
A guide to the possible price which could be obtained for sisal geotextiles are the
prices paid now by users for other geotextiles in applications where sisal could be
considered. The prices below are in US dollars per square metre of geotextile.
The range reflects the different requirements in each application and the variety
of products available.
It would be expected that sisal erosion control geotextiles could compete with
other types and in the applications of un-paved roads/separators sisal's apparent
durability may prove to be a great advantage compared with jute and coir and
may even oust synthetics in some applications. As the cost of agro-mulch films is
very low it is unlikely that a sisal geotextile could be produced at that cost level.
However if the technical advantages of a geotextile are promoted by suppliers
and are understood by users then they may be willing to pay a small cost
premium above the film cost.
Whilst the first geotextiles used were of natural fibres it was the petro-chemical
industry which seized the opportunity to sell large quantities of synthetic textiles
into civil engineering projects. The mass market was established by the
widespread use of synthetic geotextiles which continue to dominate. Therefore
for sisal to impact this market the sisal suppliers will be forced to provide similar
services to the users and specifiers at similar costs. If sisal suppliers can improve
on the services offered by the manufacturers of synthetics and at a more
economic cost then sisal could start to make serious inroads into this mass
market which is growing at a spectacular rate.
Price
Application
US $ per sq metre
Erosion Control
Synthetic 1.00 - 3.00
Woodfibre/Straw 0.55 - 1.10
Jute 0.30 - 1.00
Coir 0.90 - 2.20
Agro-mulching
Plastic film (not geotextile) 0.10 - 0.25
Un-paved roads/separators
Synthetic 3.00 - 5.00
Jute 0.60 - 1.00
Coir 0.90 - 2.20
Fig 11: Unconfined Compressive Strength for Clay Soil and 20mm Sisal
Fibres Source: Balamu (1998).
6 CONCLUSION
The market for geotextiles is growing at an exceptional rate, and in the year 2000
some 1400 million square metres of geotextiles were sold. New applications are
being found and new products developed at great rate. There is an established
market for natural fibre geotextiles and in some applications they have
characteristics superior to synthetics but they often come second best due to the
ability of the synthetic geotextile suppliers in meeting users demands for technical
data.
Sisal geotextiles could compete with other natural fibre geotextiles and would be
expected to have some properties superior to other natural fibres. Further study
of these properties should be carried out in order to establish a good data bank of
knowledge and to also focus on those applications where synthetics have the
monopoly and where prices paid are high. This work would benefit from the
support and sponsorship of all sisal producing countries in order to catch up with
the work already produced by the petro-chemical companies who manufacture
synthetic geotextiles and to compete in this technical field.
One interesting development[21] in this field is the use of composite geotextiles
incorporating different materials. An example is the combination of straw fibres
and a synthetic mesh to form an erosion control geotextile - the straw provides
the erosion control properties and the mesh gives structural form and strength to
the geotextile improving handling characteristics and the product's fixity to the
ground. This trend of combining materials is expected to continue and the
barriers between synthetic and natural fibre geotextiles will be less rigid. It may
be of benefit to sisal producers to form alliances now with the producers of
synthetics as it is likely that the producers of other natural fibres will do so.
APPENDIX: SOURCES OF INFORMATION ON GEOTEXTILES
International Geosynthetics Society.
Chapters are established in: Brazil, China, France, Germany, India, Indonesia,
Italy, Japan, Korea, Netherlands, North America (Canada & USA), Romania,
South Africa, United Kingdom, West Pacific Region (Taiwan).
Here geosynthetics has a broad definition for the purposes of the IGS and
includes natural fibre products and other in-soil related products and
technologies.
REFERENCES
Balamu P.B., (1998), Reinforcement of Soils with Natural Fibre Sisal, MSc
Thesis, Birmingham University, United Kingdom.
CFC & IJO, (1998), Jute Geotextiles Techno-Economic Manual. CFC & IJO.
Giroud J. P. & J. Perfetti, (1977), Classification des textiles et measures de leurs
proprit en vue de leur utilisation en gotechnique. Proc. Int. Conf. on Use of
Fabrics in Geotechnics.
Ingold T. S., (1994), Geotextiles & Geomembranes Manual. Elsevier.
Smith R. J. H., (1997), Goeotextile Applications, Seminar: Jute Geotextiles,
United Nations International Trade Centre, Geneva & London.
Smith R. J. H., (1998a), Back to Nature, Ground Engineering Journal, March.
Emap.
Smith R. J. H., (1998b), Geotextiles Applications, Japan Textile Importers
Association, Seminar, (unpublished).
Smith R. J. H.,(1998c), Le Jute: Ecologique, Economique, Polyvalent (in French),
TUT La Revue Europenne des Utilisateurs de Textiles Techniques, Juin-Aout,
Pub Institute Textile de France.
Wibisono G., (2000), The effect of water on the erodibility of a fibre reinforced or
stabilised kaolin, MSc Thesis, University of Birmingham, UK.
[11] Elwood Consultants Ltd, Elwood House, Cross Road, Albrighton,
Wolverhampton, WV7 3RA UK. Phone: +44 1902 372765, Fax: +44 1902
373551; E-mail: rjhsgeo@hotmail.com
[12] Giroud & Perfetti (1977).
[13] Ingold (1994)
[14] Smith (1997).
[15] CFC & IJO (1998).
[16] Wibisono (2000).
[17] Smith (1998a).
[18] Smith (1998a).
[19] Smith (1998c).
[20] CFC & IJO (1998)
[21] Smith (1998b).