Sunteți pe pagina 1din 3

current current The voltage

than 100
New dB. The drain, is a ammeter drop across
to the shown the input of
op- OP-41 respectabl
e 1.3 V/s. guarantee negative unity gain, industry here in the OP-41
also has
amps improved
Offset volt- d gain of1
million into
overdriv
e takes
the output
can drive
standard
741 make
Fig.
The
1. is less than
500 V, so
age has
linearity, been a 2K load. only 100 250 pF it simple circuit that makes
THE OP- and sta- Linearity ns. without for the can mea- it effective
reduced to
AMP IS bilized is good in The oscillating. designer to sure as a low
less than
STILL bias 500 V so both high superior The OP- up grade current as current
ONE OF current external and low perform 41'S an existing low as a metering
THE nulling is gain ance superior low power few pA device.
with configurati characte characteri and. as
MOST un- bipolar/JF The
changing ons. As a ristics of stics and a ET design. high as
widely necessary circuit
common- voltage the OP- pin out An 11- 100 A in
used in many works as
mode follower, 41 make that is page data six switch
linear IC's. application follows.
voltage. the CMRR it an identical sheet ranges.
The OP- s.
The effects excellent contains Unlike
41 op- Other
OP-41 dominate output performan many low
features
amp from consume linearity, amplifier ce curves current
include a
PMI s only and, in for a for various am-
maximum
(Precision 750 A high-gain CMOS characteris meters,
bias
Monolithic and it service, DAC tics the one
current of
s, Inc., has a open-loop (Digital including shown
five pA,
power- gain to bias cur- here does
P.O. Box and a
supply dominates analog rent vs. not
58020, rejection linearity. Convert require
temperatur
Santa ratio of Further, er). The e, bias high-
Clara, CA 25 V/V. the OP- OP-41's current vs. value
95052) is Those 41 low, common- precision
a new factors recovers stable mode resistors.
device make the rapidly bias voltage, As you
that OP-41 from current supply can see,
ideal for signal would current vs. the desir-
supply ed range
voltage, is
and power- selected
supply from a
rejection tap on a
vs. fre- voltage
quency. divider
Also made up
included in of six 1%
the data (or better)
sheet are 511-ohm
circuits for resistors.
testing and The
measuring ammeter'
performan s
ce charac- accuracy
teristics. is1% or
In better
addition, over most
several of its
application range;
s accuracy
diagrams, depends
including a on the
FIG.1 high Q decade
notch filter, resistors
a current (R6-R11)
to voltage and on
converter, the OP-
and an 41'S input
amplifier bias
for current.
features a use in overload. make it Any
piezoelectr
cascode battery- Following an good
ic
FET-input powered saturation excellent ammeter
transducer
stage that systems. at the choice should
s, are in-
Slew rate positive as a cause
has a cluded. But
is supply, photodio very little
CMRR perhaps
symmetri the output de voltage
(Common the most
cal, and, recovers amplifier drop
Anode interesting
despite in only 6 in across its
Rejection and useful
the s, and medical input
application
/Patio) of device's recovery applicati terminals.
is the low
greater low from a ons. At

S-ar putea să vă placă și