Documente Academic
Documente Profesional
Documente Cultură
1. IDENTIFICATION
Product Name Fiberglass Insulation Made with PureFiber Technology Faced Products
Synonyms Acoustical Backing Board, Attic Door Insulator, Attic Hatch Insulator, R-13 Basement
Finishing System, Batts in Bags, Cathedral Batt Insulation, Cavity Wall, Certified R,
EcoTouch, Extended Flange 25, Flame Spread 25 Hi-Perm Residential/Commercial
Insulation, Insulation Batts & Rolls, Insulation for Flexible Duct, Manufactured Housing
Insulation, MBI Plus, Metal Building Insulation, Metal Building Utility Blanket, Metal Framing
Batts, Metal Framing Insulation, NOISE Stop Blanket, PINK Insulation, PROPINK Fast
Batt,Qui et ZoneAcoust i
cBat t,Sonobat ts,Ai slhogar ,Aislacustic,DecoSKY, RA
Series Insulation, UtiliCore HP5
2. HAZARDS IDENTIFICATION
OSHA Regulatory Status This chemical is not considered hazardous by the 2012 OSHA Hazard Communication
Standard (29 CFR 1910.1200).
This product is considered an article. 29 CFR 1910.1200(c) definition of an article is as
follows: "Article" means a manufactured item other than a fluid or particle: (i) which is
formed to a specific shape or design during manufacture; (ii) which has end use function(s)
dependent in whole or in part upon its shape or design during end use; and (iii) which under
normal conditions of use does not release more than very small quantities, e.g., minute or
trace amounts of a hazardous chemical (as determined under paragraph (d) of this section),
and does not pose a physical hazard or health risk to employees
WHMIS Regulatory Status Manufactured articles which meet the definition of the Canadian Hazardous Products Act
(any article that is formed to a specific shape or design during manufacture, the intended
use of which when in that form is dependent in whole or in part on its shape or design, and
that, when being installed, if the intended use of the article requires it to be installed, and
under normal conditions of use, will not release or otherwise cause an individual to be
exposed to a hazardous product) are not regulated by the Canadian Hazardous Products
Regulation SOR/2015-17
Label elements
The product contains no substances which at their given concentration, are considered to be hazardous to health
_____________________________________________________________________________________________
Page 1 / 7
OCIS00021 - Fiberglass Insulation Made with Revision Date 07-Apr-2016
PureFiber Technology Faced Products
_____________________________________________________________________________________________
3. COMPOSITION/INFORMATION ON INGREDIENTS
Mixture
Components
Fiberglass, Wool 85-100%
Binder - EcoTouch - 0-15%
Eye contact Ri
nseimmedi at
elywithplentyofwater,alsoundertheeyeli
ds,f
oratl
east15mi
nut
es
DO NOTr uborscratcheyes
I
feyeir
rit
ati
onpersists:Getmedicaladvice/at
tent
ion
Ri
nsethoroughl
ywi thplent
yofwat er
,alsoundert heeyel
ids
I
fsymptomspersist
,cal laphysi
ci
an
Inhalation Removetof
reshai
r
I
fsympt
omspersi
st
,cal
laphysi
ci
an
5. FIRE-FIGHTING MEASURES
Suitable extinguishing media Useex t
inguishingmeasurest
hatar
eappr
opr
iat
etol
ocalci
rcumst
ancesandt
he
surrounding environment
_____________________________________________________________________________________________
Page 2 / 7
OCIS00021 - Fiberglass Insulation Made with Revision Date 07-Apr-2016
PureFiber Technology Faced Products
_____________________________________________________________________________________________
Explosion data
Sensitivity to Mechanical Impact Noi
nfor
mat
i
onav
ail
abl
e
Sensitivity to Static Discharge Noinfor
mat
i
onav
ail
abl
e
Personal precautions Av
oidcont
actwi
theyesandski
n
_____________________________________________________________________________________________
Page 3 / 7
OCIS00021 - Fiberglass Insulation Made with Revision Date 07-Apr-2016
PureFiber Technology Faced Products
_____________________________________________________________________________________________
Control parameters
Exposure Guidelines .
Engineering Controls Provide local exhaust and/or general ventilation to maintain exposure below regulatory and
recommended limits
Dust collection system must be used in transferring operations, cutting or other dust
generating processes, such as using power tools
Vacuum or wet clean-up methods should be used
Chemical stability St
abl
eunderr
ecommendedst
oragecondi
ti
ons
Conditions to avoid Ex
tremesoft
emper
atur
eanddi
rectsunl
i
ght
_____________________________________________________________________________________________
Page 4 / 7
OCIS00021 - Fiberglass Insulation Made with Revision Date 07-Apr-2016
PureFiber Technology Faced Products
_____________________________________________________________________________________________
Product Information Fi
berglasswoolmaycauset empor ar
yski
nandmucousmembr
anesi
tchi
ngduet
o
mechanical abrasion effect of fibers
Delayed and immediate effects as well as chronic effects from short and long-term exposure
Ecotoxicity Thi
spr
oducti
snotex
pect
edt
obehazar
dousf
ort
heenv
ironment
Bioaccumulation Noi
nfor
mat
ionav
ail
abl
e
_____________________________________________________________________________________________
Page 5 / 7
OCIS00021 - Fiberglass Insulation Made with Revision Date 07-Apr-2016
PureFiber Technology Faced Products
_____________________________________________________________________________________________
Note: These products are not classified as dangerous goods according to international transport
regulations
Legend:
TSCA - United States Toxic Substances Control Act Section 8(b) Inventory
DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List
EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances
ENCS - Japan Existing and New Chemical Substances
IECSC - China Inventory of Existing Chemical Substances
KECL - Korean Existing and Evaluated Chemical Substances
PICCS - Philippines Inventory of Chemicals and Chemical Substances
AICS - Australian Inventory of Chemical Substances
US Federal Regulations
SARA 313
Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any
chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372
_____________________________________________________________________________________________
Page 6 / 7
OCIS00021 - Fiberglass Insulation Made with Revision Date 07-Apr-2016
PureFiber Technology Faced Products
_____________________________________________________________________________________________
CERCLA
This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive
Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and
Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level
pertaining to releases of this material
US State Regulations
California Proposition 65
This product does not contain any Proposition 65 chemicals
Disclaimer
Reasonable care has been taken in the preparation of this information, but the manufacturer makes no warranty of merchantability
or any other warranty, expressed or implied, with respect to this information. The manufacturer makes no representations and
assumes no liability for any direct, incidental or consequential damages resulting from its use
_____________________________________________________________________________________________
Page 7 / 7