Documente Academic
Documente Profesional
Documente Cultură
Battery Warnings
Step 2 From a computer (3-5 hours) Treatment successful but
Place lamp in water.
Plug the USB end of the included cord into a computers battery is low. Recharge soon.
Completely submerge metal
USB port and connect Freedom via the micro USB end of Treatment failed due to
water sensors. UV lamp will
the cord. Make sure that the computer is connected to a depleted battery. Recharge
turn on.
power source and doesnt go to sleep during charging. and treat again.
Charge complete
Hydro-Photon, Inc. (when plugged in).
PO Box 675 Step 3 From a solar charger (depends on charger)
Stir until green light. Charging
262 Ellsworth Road Connect Freedom to a solar charger via the USB cord (when plugged in).
Enjoy!
Blue Hill, ME 04614 USA and position the solar charger so that it is directly
exposed to the sun. Reposition the solar charger during Lamp Warnings
Toll Free USA: 1-888-SteriPEN the day for best performance. 100 treatments remaining.
(+1) 207-374-5800
Lamp failure.
info@steripen.com
www.steripen.com No signal Battery depleted. Recharge.
tampering with the electronic circuit board or lamp allowed in carry-on bags, as well as checked Limited Lifetime Warranty for any manufacturing defect. For product
registration and complete warranty information, please visit
assembly may cause injury, or damage. luggage. www.steripen.com/warranty or contact your local distributor.
Flashlight Operation
Do not open, expose, modify or touch internal While carefully controlled microbiological testing of Freedom has
Does altitude affect Freedoms ability to purify been conducted, use in the eld may produce results that vary from
circuitry; doing so can lead to high voltage shock. To activate LED ashlight hold Freedom by the lamp
water? our laboratory test data.
Do not attempt to bypass water sensor; it is an This Class B digital apparatus complies with Canadian ICES-003. cover end and rotate wrist in 180 turns (as if you
important safety feature. No. SteriPEN technology and product design Cet appareil numrique de la classe B est conforme la norme were slowly turning a doorknob back and forth). To
NMB-003 du Canada. turn ashlight off, repeat wrist rotations.
As with other uorescent-type lamps, Freedom have been tested and used on Mount Everest for
NOTE: This equipment has been tested and found to comply with
contains a small amount of mercury. At the end of years. the limits for a Class B digital device, pursuant to Part 15 of the FCC
its life, please dispose of Freedom properly. For Rules. These limits are designed to provide reasonable protection
specic instsructions contact your local waste Can I use Freedom to treat more than 1 liter at against harmful interference in a residential installation. This
a time? equipment generates, uses and can radiate radio frequency energy
disposal organization. and, if not installed and used in accordance with the instructions,
may cause harmful interference to radio communications. However,
Freedom is not intended to treat liquids other than No, we do not recommend it. You may treat 1 there is no guarantee that interference will not occur in a particular
water. liter volumes by repeating the 48-second installation. If this equipment does cause harmful interference to
treatment a second time (96 seconds of total UV radio or television reception, which can be determined by turning the
Do not use UV lamp as a light source (thats what equipment off and on, the user is encouraged to try to correct the
the ashlight is for). exposure time). Freedoms effectiveness is ONLY interference by one or more of the following measures:
tested and certied on volumes up to 1 liter. Reorient or relocate the receiving antenna.
Do not use near skin, eyes or insert into bodily Increase the separation between the equipment and receiver.
orices. Connect the equipment into an outlet on a circuit
What about parasites like worms and their
different from that to which the receiver is connected.
Do not use in water above 140F/60C. eggs? Does Freedom treat for them? Consult the dealer or an experienced radio/TV technician for help.
As with any other water treatment system, always Warning: Changes or modications to this unit not expressly
have a backup method. Due to animal testing restrictions, Freedoms approved by the party responsible for compliance could void the
effectiveness against such parasites has not user authority to operate the equipment under FCC rules.
While carefully controlled microbiological testing of been certied.
all SteriPEN products has been conducted, use of
all SteriPEN products in the eld may produce
results that vary from our laboratory test data. GMAA