Documente Academic
Documente Profesional
Documente Cultură
www.12voltshop.com
that may cause undesired operation.
Car Alarm System AM-777 Installation and Owners Manual 2 Car Alarm System AM-777 Installation and Owners Manual
System Contents Wire Harness Description
1 Base Control Module 2 3 Button Transmitter 6 PIN DOORLOCK WIRING HARNESS
1 6 Pin Main Power Harness & Connector 1 Instructions Owners, Install, Warranty PIN# Color Description
1 14 Pin Input/Output Harness & Connector 1 Antenna
1 20W Siren 1 Impact Shock Sensor 1 BROWN/ LOCK NORMALLY
BLUE OPEN
2 BLUE/ LOCK COMMON
Remote Control WHITE
3 ORANGE/ LOCK NORMALLY
BLUE CLOSED
4 BROWN/ UNLOCK NORMALLY OPEN
GREEN
5 GREEN/ UNLOCK COMMON
WHITE
6 ORANGE/ UNLOCK NORMALLY CLOSED
GREEN
Car Alarm System AM-777 Installation and Owners Manual 3 4 Car Alarm System AM-777 Installation and Owners Manual
Features OWNERS OPERATING INSTRUCTIONS
Features OWNERS OPERATING INSTRUCTIONS
" Automatic Door Unlock
" Code Learning When the key is turned from ACC ON to ACC OFF, doors will automatically unlock.
1. Turn IGNITION ON, press Valet Switch 10 times within 8 seconds. Siren will sound 3
times to enter code learning. Then press any button on the remote control within 8
" Valet
seconds.
2. If a new remote control is to be programmed, all existing remote controls must be 1. Turn key to On position (ACC ON) then press valet switch one time within 8 seconds.
reprogrammed at the same time. Maximum 3 remote transmitters can be programmed. 2. In VALET mode, LED will be constantly ON even when key is turned off (ACC OFF).
3. In VALET mode: siren will sound twice and parking lights will flash twice when Lock
button is pressed.
" Arming 4. Disable VALET mode: turn key to On position (ACC ON) press valet switch one time,
1. Press Button 1 LED will turn OFF after 8 seconds.
2. Siren will sound 1 time. If in silent mode, siren will not sound.
3. Parking lights will flash 1 time. " Panic
4. Door(s) will lock, if option is installed 1. Press Button 1+2 , the siren will sound and parking lights will flash for 30 seconds.
5. LED will flash slowly. 2. Press Button 1 or 2 will stop the panic.
6. Enables (arms) engine interrupt circuit (if starter kill option has been installed)
7. After 3 seconds, alarm is armed. If the alarm is triggered within 3 sec, the circuit will be
" Car Finder
bypass, and then alarm will rearm itself
1. Alarm is armed.
" Disarming 2. Press Button 1 e: siren will sound once and parking lights will flash 10 times
3. Press Button 3: car finder in silent situation (parking lights will flash 10 times but there
1. Press Button 2
will be no siren sound)
2. Siren will sound 3 times. If siren sounds 4 times, it means the alarm has been trigger.
4. Press Button 2 to stop it.
If silent mode arming, the parking lights will flash but without siren sound.
3. Parking lights will flash 3 times, if lights flash 4 times, it means the alarm has been
activated. " Shock Sensor
4. Doors will unlock at 0.5sec or 3.5sec (choose jumper position). 1. If car senses light impact once, siren will sound for 1 second. If car senses light impact
5. Disables engine interrupt circuit (if starter kill relay is connected). again within 8 seconds, siren will sound and parking lights flash for 30 seconds.
6. If alarm is on automatic re-arming function, LED will flash quickly. After 30 seconds 2. If car receives a heavy impact shock, siren will sound for 30 seconds and parking lights
alarm will automatically rearm. will flash for 30 seconds.
Car Alarm System AM-777 Installation and Owners Manual 5 6 Car Alarm System AM-777 Installation and Owners Manual
" Door Lock Control Indications
1. Driving: Press Button 1 to lock doors. LED conditions
2. Press Button 2 to unlock doors. 1. When alarm armed, LED will flash slowly 1 time/sec.
2. When alarm armed, if alarm activates, LED will constantly flash quickly.
3. When alarm is disarmed, if ACC is not switched ON / door not open, after 30 sec it will be
" Automatic Rearming automatically rearmed.
When alarm is disarmed, If ACC is not turned ON & door(s) not opened, the system will 4. Valet mode: LED constantly on.
automatically rearm after 30 secs.
Parking lights emergency flash
Features OWNERS OPERATING INSTRUCTIONS In armed mode, parking lights will flash for 30 seconds if triggered.
" Door-Opened Warning Siren emergency sound
If one of the doors is opened when ignition is ON, the system will flash for 1 minute to warn In armed mode, siren will sound for 30 seconds if triggered.
door is open. (installation optional feature-see jumper position).
Function Choice
There are five jumper selection (J1 J5). See the table as below:
Important: All jumper selections has to be determined before installation. Otherwise, you have to
power off the module again for reset.
Car Alarm System AM-777 Installation and Owners Manual 7 8 Car Alarm System AM-777 Installation and Owners Manual
Wiring Diagram Door Lock Systems
For vehicles requiring ADD-ON actuators for power door lock option.
For vehicles equipped with VACUUM door lock system (i.e. MERECDES)
Find the BLUE wire in the drivers kick panel or the Lt. GREEN wire in the passenger kick
panel. The control wire will show 12 Volts when doors are UNLOCKED and ground when the
doors are LOCKED. For this locking system you will need to change jumper position J1 from
0.5 sec. lock time to 3.5 sec. function. (Found on page 6)
Connect the Brown/Blue wire to CHASSIS GROUND.
Connect the Blue/White wire to the Orange/Green. Both wires are found on the same plug.
Connect the Orange/Blue wire to the blue wire coming from the door actuator. This blue wire
is joined to the servomotor, which must be cut in order to operate
Connect the Brown/Green wire to 12 Volt Constant.
Connect the Green/White wire to the blue wire coming from the servomotor. This blue wire is
joined to the door actuator, which must be cut in order to operate.
Connect the Orange/Green wire to the Blue/White. Both wires are found on the same plug.
NOTE: If when testing the BLUE or Lt. GREEN door lock wires and it is found that the
UNLOCK is a negative signal and the LOCK is a positive signal when testing, then the
BROWN/BLUE wire must go to 12Volts constant and the BROWN/GREEN wire must go to a
chassis ground.
Car Alarm System AM-777 Installation and Owners Manual 9 10 Car Alarm System AM-777 Installation and Owners Manual
Door Lock Systems
This type of door lock system does not require factory-installed relays to operate. In order to
test for this type of system you must access the lock and unlock wires coming from door lock
switch (may be found in the drivers kick panel). Test these wires for a positive signal when
toggling door lock switch between lock and unlock. When you have these wires located cut
one in half and check to see if the lock and unlock operation has stop working, if so determine
which half is for the switch side and which is the motor side.
Connect the Brown/Blue wire to 12 Volts constant.
Connect the Blue/White wire to the door lock motor side wire.
Connect the Orange/Blue wire to the door lock switch side wire.
Connect the Brown/Green wire to 12 Volts constant.
Connect the Green/White wire to the door unlock motor side wire.
Connect the Orange/Green wire to the door unlock switch side wire.
Car Alarm System AM-777 Installation and Owners Manual 11 12 Car Alarm System AM-777 Installation and Owners Manual
Car Alarm System AM-777 Installation and Owners Manual 13