Documente Academic
Documente Profesional
Documente Cultură
3) I n a automatic loom
i. Weft-break is repaired automatically
ii. Warp-break is repaired automatically
iii. Exhausted weft bobbin is replaced automatically
a. Twill
b. Satin
c. Jacquard
d. Terry
15)The factor that does not influence the propelling force for moving the weft yarn
on air jet loom is
a. Coefficient of friction between air and yarn
b. Air velocity
c. Yarn strength
d. Yarn diameter
16)A 51 mm long fibre has 6 % crimp. The crimped length of the fibre in mm is
approximately
a. 44
b. 46
c. 48
d. 50
17) Increase in taper angle on sectional warping drum will normally require
a. Higher Warping Speed
b. Lower Warping Speed
c. Increase in traverse speed
d. Decrease in traverse speed
18) Which of the following woven structure gives maximum amount of support to
adjacent threads
a. Twill
b. Plain
c. Satin
d. Crepe
19) Increase in the ratio of the length of crank to the length of connecting rod leads to
a. Increase in sley eccentricity
b. Decrease in sley eccentricity
3
c. No change in sley eccentricity
d. Initial increases and then decreases
20)Shuttle remains on the race board during its flight in the shed because of
a. Forward positive acceleration of the sley
b. Backward positive acceleration of the sley
c. Constant forward velocity
d. Constant backward velocity
21) In a given woven fabric the extension at break in weft direction is higher than that
in warp
direction. During bursting strength test, the threads that will always break first are
a. Warp
b. Weft
c. Both Warp & Weft simultaneously
d. Lower strength
26) Peg plan in point paper representation of weave design is used for
a. Reed selection
b. Heald lifting order
c. Beat up force
4
d. Fell of the cloth
27)For weaving a fabric in reversible satin (1/4 and 4/1 weave) minimum
number of heald frame required to weave the design ___________
29)The minimum number of heald frame required to weave double cloth _______