Documente Academic
Documente Profesional
Documente Cultură
1
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD
IV B.Tech. I Sem., I Mid-Term Examinations, September-2017
HORIZONTAL WELL TECHNOLOGY
Objective Exam
Name: ______________________________ Hall Ticket No. A
Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10.
1. Apart from Drilling Engineer which of the following professionals is important in the success of a
Horizontal Well project. [ ]
a) Reservoir Engineer b) Production Engineer c) Completion Engineer d) All
2. Which one of the following horizontal well is designed to drain multiple layers [ ]
a) Staircase Well b) Short Radius Well c) Medium Radius Well d) Long Radius Well
3. If the turning radius for a horizontal well is 30 ft, it belongs to which of the following category
[ ]
a) Ultra Short Radius b) Short Radius c) Medium Radius d) Long Radius
4. What factors should be considered while selecting a completion scheme for horizontal wells[ ]
a) Production Mechanism b) Formation c) Simulation Requirements d) All of the above
5. If the permeability of the un-invaded is 200 mD and the skin factor is zero what will be the
permeability of the invaded zone. [ ]
a) 100 mD b) 200 mD c) 300 mD d) None of the above
6. Under similar reservoir conditions the well spacing provided for horizontal well development will be
[ ]
a) Less than that for vertical well b) Greater than for vertical well
c) Equal to that for vertical well d) None of the above
7. Which of the following well preforms better in terms of productivity index when the reservoir
thickness is increased [ ]
a) Vertical Wells b) Horizontal Wells c) Slant Wells d) All are equally good
9. Which of the following can be a reason for higher formation damage in horizontal well in comparison
with vertical well. [ ]
a) Horizontal well required more time for drilling b) Horizontal well required less time for drilling
c) Under balanced drilling in horizontal well d) None of the above
10. The reservoir is said to be infinitely acting under which of the following condition [ ]
a) Before the pressure disturbance reach the reservoir boundary
b) After the pressure disturbance reach the reservoir boundary
c) Both A and B d)None of the above
Cont..2
Code No: 117DR :2: Set No. 1
11. In naturally fractured reservoirs ______________________ wells are used to intersect more fractures
and drain the reservoir more effectively.
12. In high permeable gas reservoirs, the horizontal well _________________ near well turbulence and
improves well deliverability.
13. Theoretically horizontal wells can be represented as vertical well with large ____________________
skin factor.
14. If a well is producing at a rate of 800 bbl/day for a pressure drawdown of 400 psi, then the
productivity index of the well is _________________ bbl/day/psi.
15. In a naturally fractured reservoir the horizontal wells are drilled in a direction _____________ to the
natural fractures.
16. The horizontal wells are preferred in reservoirs whose vertical permeability is ________________than
horizontal permeability
17. For a given skin factor the pressure drop in the skin region for horizontal well will be
___________________ than that for vertical well as the pressure drop is proportional to the flow rate.
18. The productivity index of a vertical well is __________________ proportional to the pay zone
thickness for a given drainage area.
20. The horizontal well will act as infinite conducting fracture when the value of _________________
skin factor is less.
-oOo-
Code No: 117DR Set No. 2
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD
IV B.Tech. I Sem., I Mid-Term Examinations, September-2017
HORIZONTAL WELL TECHNOLOGY
Objective Exam
Name: ______________________________ Hall Ticket No. A
Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10.
1. What factors should be considered while selecting a completion scheme for horizontal wells[ ]
a) Production Mechanism b) Formation c) Simulation Requirements d) All of the above
2. If the permeability of the un-invaded is 200 mD and the skin factor is zero what will be the
permeability of the invaded zone. [ ]
a) 100 mD b) 200 mD c) 300 mD d) None of the above
3. Under similar reservoir conditions the well spacing provided for horizontal well development will be
[ ]
a) Less than that for vertical well b) Greater than for vertical well
c) Equal to that for vertical well d) None of the above
4. Which of the following well preforms better in terms of productivity index when the reservoir
thickness is increased [ ]
a) Vertical Wells b) Horizontal Wells c) Slant Wells d) All are equally good
6. Which of the following can be a reason for higher formation damage in horizontal well in comparison
with vertical well. [ ]
a) Horizontal well required more time for drilling b) Horizontal well required less time for drilling
c) Under balanced drilling in horizontal well d) None of the above
7. The reservoir is said to be infinitely acting under which of the following condition [ ]
a) Before the pressure disturbance reach the reservoir boundary
b) After the pressure disturbance reach the reservoir boundary
c) Both A and B d)None of the above
8. Apart from Drilling Engineer which of the following professionals is important in the success of a
Horizontal Well project. [ ]
a) Reservoir Engineer b) Production Engineer c) Completion Engineer d) All
9. Which one of the following horizontal well is designed to drain multiple layers [ ]
a) Staircase Well b) Short Radius Well c) Medium Radius Well d) Long Radius Well
10. If the turning radius for a horizontal well is 30 ft, it belongs to which of the following category
[ ]
a) Ultra Short Radius b) Short Radius c) Medium Radius d) Long Radius
Cont..2
Code No: 117DR :2: Set No. 2
11. If a well is producing at a rate of 800 bbl/day for a pressure drawdown of 400 psi, then the
productivity index of the well is _________________ bbl/day/psi.
12. In a naturally fractured reservoir the horizontal wells are drilled in a direction _____________ to the
natural fractures.
13. The horizontal wells are preferred in reservoirs whose vertical permeability is ________________than
horizontal permeability
14. For a given skin factor the pressure drop in the skin region for horizontal well will be
___________________ than that for vertical well as the pressure drop is proportional to the flow rate.
15. The productivity index of a vertical well is __________________ proportional to the pay zone
thickness for a given drainage area.
17. The horizontal well will act as infinite conducting fracture when the value of _________________
skin factor is less.
18. In naturally fractured reservoirs ______________________ wells are used to intersect more fractures
and drain the reservoir more effectively.
19. In high permeable gas reservoirs, the horizontal well _________________ near well turbulence and
improves well deliverability.
20. Theoretically horizontal wells can be represented as vertical well with large ____________________
skin factor.
-oOo-
Code No: 117DR Set No. 3
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD
IV B.Tech. I Sem., I Mid-Term Examinations, September-2017
HORIZONTAL WELL TECHNOLOGY
Objective Exam
Name: ______________________________ Hall Ticket No. A
Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10.
1. Under similar reservoir conditions the well spacing provided for horizontal well development will be
[ ]
a) Less than that for vertical well b) Greater than for vertical well
c) Equal to that for vertical well d) None of the above
2. Which of the following well preforms better in terms of productivity index when the reservoir
thickness is increased [ ]
a) Vertical Wells b) Horizontal Wells c) Slant Wells d) All are equally good
4. Which of the following can be a reason for higher formation damage in horizontal well in comparison
with vertical well. [ ]
a) Horizontal well required more time for drilling b) Horizontal well required less time for drilling
c) Under balanced drilling in horizontal well d) None of the above
5. The reservoir is said to be infinitely acting under which of the following condition [ ]
a) Before the pressure disturbance reach the reservoir boundary
b) After the pressure disturbance reach the reservoir boundary
c) Both A and B d)None of the above
6. Apart from Drilling Engineer which of the following professionals is important in the success of a
Horizontal Well project. [ ]
a) Reservoir Engineer b) Production Engineer c) Completion Engineer d) All
7. Which one of the following horizontal well is designed to drain multiple layers [ ]
a) Staircase Well b) Short Radius Well c) Medium Radius Well d) Long Radius Well
8. If the turning radius for a horizontal well is 30 ft, it belongs to which of the following category
[ ]
a) Ultra Short Radius b) Short Radius c) Medium Radius d) Long Radius
9. What factors should be considered while selecting a completion scheme for horizontal wells[ ]
a) Production Mechanism b) Formation c) Simulation Requirements d) All of the above
10. If the permeability of the un-invaded is 200 mD and the skin factor is zero what will be the
permeability of the invaded zone. [ ]
a) 100 mD b) 200 mD c) 300 mD d) None of the above
Cont..2
Code No: 117DR :2: Set No. 3
11. The horizontal wells are preferred in reservoirs whose vertical permeability is ________________than
horizontal permeability
12. For a given skin factor the pressure drop in the skin region for horizontal well will be
___________________ than that for vertical well as the pressure drop is proportional to the flow rate.
13. The productivity index of a vertical well is __________________ proportional to the pay zone
thickness for a given drainage area.
15. The horizontal well will act as infinite conducting fracture when the value of _________________
skin factor is less.
16. In naturally fractured reservoirs ______________________ wells are used to intersect more fractures
and drain the reservoir more effectively.
17. In high permeable gas reservoirs, the horizontal well _________________ near well turbulence and
improves well deliverability.
18. Theoretically horizontal wells can be represented as vertical well with large ____________________
skin factor.
19. If a well is producing at a rate of 800 bbl/day for a pressure drawdown of 400 psi, then the
productivity index of the well is _________________ bbl/day/psi.
20. In a naturally fractured reservoir the horizontal wells are drilled in a direction _____________ to the
natural fractures.
-oOo-
Code No: 117DR Set No. 4
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD
IV B.Tech. I Sem., I Mid-Term Examinations, September-2017
HORIZONTAL WELL TECHNOLOGY
Objective Exam
Name: ______________________________ Hall Ticket No. A
Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10.
2. Which of the following can be a reason for higher formation damage in horizontal well in comparison
with vertical well. [ ]
a) Horizontal well required more time for drilling b) Horizontal well required less time for drilling
c) Under balanced drilling in horizontal well d) None of the above
3. The reservoir is said to be infinitely acting under which of the following condition [ ]
a) Before the pressure disturbance reach the reservoir boundary
b) After the pressure disturbance reach the reservoir boundary
c) Both A and B d)None of the above
4. Apart from Drilling Engineer which of the following professionals is important in the success of a
Horizontal Well project. [ ]
a) Reservoir Engineer b) Production Engineer c) Completion Engineer d) All
5. Which one of the following horizontal well is designed to drain multiple layers [ ]
a) Staircase Well b) Short Radius Well c) Medium Radius Well d) Long Radius Well
6. If the turning radius for a horizontal well is 30 ft, it belongs to which of the following category
[ ]
a) Ultra Short Radius b) Short Radius c) Medium Radius d) Long Radius
7. What factors should be considered while selecting a completion scheme for horizontal wells[ ]
a) Production Mechanism b) Formation c) Simulation Requirements d) All of the above
8. If the permeability of the un-invaded is 200 mD and the skin factor is zero what will be the
permeability of the invaded zone. [ ]
a) 100 mD b) 200 mD c) 300 mD d) None of the above
9. Under similar reservoir conditions the well spacing provided for horizontal well development will be
[ ]
a) Less than that for vertical well b) Greater than for vertical well
c) Equal to that for vertical well d) None of the above
10. Which of the following well preforms better in terms of productivity index when the reservoir
thickness is increased [ ]
a) Vertical Wells b) Horizontal Wells c) Slant Wells d) All are equally good
Cont..2
Code No: 117DR :2: Set No. 4
11. The productivity index of a vertical well is __________________ proportional to the pay zone
thickness for a given drainage area.
13. The horizontal well will act as infinite conducting fracture when the value of _________________
skin factor is less.
14. In naturally fractured reservoirs ______________________ wells are used to intersect more fractures
and drain the reservoir more effectively.
15. In high permeable gas reservoirs, the horizontal well _________________ near well turbulence and
improves well deliverability.
16. Theoretically horizontal wells can be represented as vertical well with large ____________________
skin factor.
17. If a well is producing at a rate of 800 bbl/day for a pressure drawdown of 400 psi, then the
productivity index of the well is _________________ bbl/day/psi.
18. In a naturally fractured reservoir the horizontal wells are drilled in a direction _____________ to the
natural fractures.
19. The horizontal wells are preferred in reservoirs whose vertical permeability is ________________than
horizontal permeability
20. For a given skin factor the pressure drop in the skin region for horizontal well will be
___________________ than that for vertical well as the pressure drop is proportional to the flow rate.
-oOo-