Sl. No Description Yes No Period Remarks/Observation
1 Isolate the incoming source and apply LOTO. F/Q Make sure that supply is not available at the i/p terminal of the 2 F/Q equipment 3 Ensure all Indication lamps are glowing Q Check for any cable colour change at contactors / connectors / 4 Q isolators etc and attend if so. 5 Check and Tight all the Electrical connections Q 6 Check the AHU running in "VFD" mode and "BYPASS" Mode. Q 7 Check the Motor body double earthing Q 8 Check the Motor terminal and log the Winding Resistance Q 9 Ensure the AHU inside lights are working if not correct it Q Check and Ensure the AHU should stop opening the door while 10 running if not check the limit switch operation. Q Check the Heating Element and Heater circuit. Log the heater 11 Load current Q 12 Clean the control panel and Isolator switch with blower. Q Load Current 13 Log motor load current (max) ,KWH Reading and Run hours KWH Reading Q Run Hours 14 Check blower V-belt tension . Q 15 Ensure all valves are easy to operating if not lubricate the valve Q 16 Clean condensate drain pan and free from dust. Q 17 Check the tightness of Motor and Blower base bolts. Q 18 Clean filter with water and dry properly. M 19 Check the Actuator properly working Q Check and log the "T" across the cooling coil and Return Air 20 Temperature, canvass Temperature. Q 21 Check and Log the Balancing Valve position Q Check and Ensure the Pressure gauges and Temperature 22 sensors are properly working Q Done by : Spares used