Documente Academic
Documente Profesional
Documente Cultură
Install the device safely inside the vehicle in the recommended location
GUIDE TO USE IN A AUTOMOBILE VEHICLE 1. Make sure all the windows are closed (leaving a small gap on the glass window for the
power cable & gently close it with a cloth to stop air leakage)
Do not stay inside the ODOUR removal results may vary based on the actual condition of 2. Open the Dashboard inside the car.
vehicle while running the the vehicle & its interior materials used. Example: Use of decorative INLET
PorTABLE UV device. materials, Type of goods stored, indoor cleanness, etc. STEP-2, Switch ON the Car/Van/Bus
1. Switch ON the Vehicle AC & keep the fan speed level between 2 to 4 for
Always read the safety instruction manual for the safe use of UV Equipment. air circulation.
2. Open the fresh air intake valve.
3. Switch ON the STERi Portable Device.
STEP-3, Waiting Time-1; Wait for 5 min (Small size vehicles); Wait for 10 min (Big, long vehicles)
For small size car place
the PorTABLE device on 1. Close the fresh air intake valve & let the UV unit, car engine & AC keep running.
the rear seat (1 nos
STEP-4, Waiting Time-2; Wait for recommended duration w.r.t to vehicle size & type.
INLET device is required)
(30min, 45min, 60min, 90min, 120min) Longer the waiting time higher the UV treatment effect.
Duration:
STEP-5, Switch OFF the UV device; Switch off the Vehicle & AC.
30 min to 60min
1. Remove the UV device safely from the vehicle.
2. Wait for 15min with all doors closed (optional & it will extend the treatment time).
3. Your vehicle is now ready to use. (If you want to immediately use the vehicle, opening all the doors &
When the rear cabin is window glass for 2~4min)
divided from the driver 4. If you want to extend the UV treatment then you can extend the Waiting time in STEP-4 & continue the
seat, then use two UV process again.
INLET
devices to save time. Note:
Example: Ambulance, 1. For better result remove all the unwanted items kept inside the vehicle.
Food truck, etc.
2. Clean your vehicle with regular method (vacuum m/c) to remove visible dust particles, waste, food items,
drinks, etc. before running the STERi equipment.
3. Do not use STERi equipment immediately after painting the interior. Wait at least for 1-week time (or as
Duration:
per painting specification) for the paint to dry completely to have better result.
60 min to 120 min
4. Devices will not remove dust particles, insects inside the vehicle.
(Longer the food trucks
INLET
treatment better the 5. Do not run the UV device when the vehicle indoor surfaces, floor and seats are wet.
results) 6. Do not rough handle the UV device; it may damage the UV unit. Always handle the device gently.
7. Once 9000 hour is completed. Please call our customer support team for service & replacement.
Duration:
45 min to 90 min For long vehicles like bus & van we highly recommend to use 2nos
Visit www.limat.xyz
PorTABLE UV devices simultaneously on two ends. Duration: 90 min to 120 min
Visit www.limat.xyz GUIDE TO USE IN A SMALL & BIG SIZE ROOMS