Documente Academic
Documente Profesional
Documente Cultură
Nanyang Tech University Library, Nanyang Technological, Version correct as of 22/08/2009 14:37,
EN 19971:2004
EN -7991:1(4002E)
(1)P For retaining structure and verifications of structural (STR) and geotechnical (GEO) limit
states, set R1, R2 or R3 of the following partial factors on resistance (R) shall be applied :
NOTE The values to be ascribed to R;v, R;h and R;e for use in a country may be found in its National
annex to this standard. The recommended values for the three sets R1, R2 and R3 are given in
Table A.13.
R1 R2 R3
A.3.3.6 Partial resistance factors (R) for slopes and overall stability
(1)P For slopes and overall stability and verifications of structural (STR) and geotechnical
(GEO) limit states a partial factor on ground resistance (R;e) shall be applied.
NOTE The value to be ascribed to R;e for use in a country may be found in its National annex to this
standard. The recommended value for the three sets R1, R2 and R3 is given in Table A.14.
Table A.14 - Partial resistance factors (R) for slopes and overall stability
R1 R2 R3
135
Licensed copy: Ms. Nanyang Tech University Library, Nanyang Technological, Version correct as of 22/08/2009 14:37,
EN 19971:2004
EN -7991:1( 4002E)
(1)P For the verification of uplift limit state (UPL) the following partial factors on actions (F)
shall be applied:
NOTE The values to be ascribed to G;dst , G;stb and Q;dst for use in a country may be found in its
National annex to this standard. The recommended values are given in Table A.15.
Permanent
Variable
(c) BSI
a
Destabilising;
b
Stabilising
(2)P For the verification of uplift limit state (UPL) the following partial factors shall be applied
when including resistances:
c on effective cohesion;
a on anchorage resistance.
NOTE The values to be ascribed to , c, cu, s;t, and a for use in a country may be found in its
National annex to this standard. The recommended values are given in Table A.16.
136
Licensed copy: Ms. Nanyang Tech University Library, Nanyang Technological, Version correct as of 22/08/2009 14:37,
EN 19971:2004
EN -7991:1(4002E)
a
This factor is applied to tan '
A.5 Partial factors for hydraulic heave limit state (HYD) verification
(1)P For the verification of hydraulic heave limit state (HYD) the following partial factors on
actions (F) shall be applied:
G;dst
NOTE The values to be ascribed to G;dst , G;stb and Q;dst for use in a country may be found in its
National annex to EN 1990:2002. The recommended values are given in Table A.17.
Permanent
Variable
a Destabilising
b Stabilising
731
137