Documente Academic
Documente Profesional
Documente Cultură
ARCHITECTURAL COATINGS
TOUCHWOOD
www.asianpaints.com/oman AC Colour
PRODUCT DESCRIPTION
BERGER Touchwood AC Colour is a premium quality two pack acid cured melamine coating, specially formulated as
a protective and decorative coating for wood for interiors.
It protects the wood for many years and has excellent resistance to staining from oils, foods and hot beverages.
It offers substantial economy in terms of durability, decorative and protective value, compared to other conventional
coatings.
TECHNICAL DATA
Finish : Gloss, Satin
Shade / Colour Range : White, Black, Red and few selected pastel shades.
Solvent Resistance : Good resistance to aliphatic, aromatic hydrocarbons & polar solvents.
Composition Nominal : Acid catalysed Alkyd / Amino system
Specific gravity : 1.20 0.10
% Volume Solids : 40 2 %
Mixing Ratio : 9:1 parts by volume (Base : Hardener)
Maturation time : 10 - 15 mins.
Pot Life : 8 hrs at 30C
Viscosity of supply : 75 - 100 sec
Gloss level at 60 head : Gloss: 80 minimum; Satin: 30 - 40
APPLICATION DATA
Method of Application : Spray at an optimal spray pressure of 30-40 psi (2.2-2.8 kg/cm2)
Brushing is recommended for Touchups only.
Thinner : Thinner: T-124
Thinning ratio (by vol.) : Spraying: 30 - 35%
SURFACE PREPARATION
Sand the Wooden surface with 180 Emery paper, followed by 320 Emery paper, dust off. Remove all grease, loose flaking
paint etc.
Stir the contents thoroughly before and during use, with a broad flat stirrer, using an upward lifting action
Touchwood AC Colour is a two-component system consisting of a hardener and a base which should be mixed in the
recommended ratio.
Allow the mixture to stand for 15 min. and apply by spraying or brushing using the recommended thinner for viscosity
adjustments.
* For detailed system recommendation based on specific requirements please contact Berger representative.
DISCLAIMER
The information provided in this data sheet is not intended to be complete. It is the responsibility of the user to ensure that the product used is suitable for the purpose it is meant to serve.
In view of various factors affecting the performance of the coating, we cannot assume responsibility for the product performance, nor do we accept any liability arising from use of this
product, unless specifcally agreed to in writing by us. The information provided in the datasheet may be modifed by us without notice.
This Technical Data Sheet supersedes those previously issued with immediate effect.
Version: 02/2007