Sunteți pe pagina 1din 1

For Epson-WP

Installation Refilling
ALL Refillable Cartridges MUST put into the Filll up the cartridge from the refill hole
printer at the same time in order to work, appx 85% full over filled will cause leakage!
as they work as a set. Air Hole
Slowly & Gentally Squeez the
Remove the Air Hole Rubber Plug on top of Ink into the cartridge tank.
each cartridges and leave it OPEN! Stop when it is about 85%

Refill
CUBE1113
Push the cartridges slightly harder than full, then put the rubber plug
normal into the printer if required. back on the cartridge.
www.cube1113.com facebook/cube1113 www.cube1113.com facebook/cube1113

Reset Troubleshooting
Only Reset the Cartridge only printer warns X If Printer Warns you that the cartridges install
Most of Refillable cartridges have Auto Reset are not Genuine Ink, just click Continue.
Chips, that just take them out and put them If the cartridge is not recognised by the
back in to reset, if your chips look like below printer, do a reset on the cartridge.
Use a paper clip or anything If there is no ink print out, make sure the air
Golden Dot
similar touching upper golden hole is open, carry out the head cleaning
dots at the same time for in the printer utility software, do few times
approx 3 to 5 seconds to reset if necessary until ink comes out properly.
www.cube1113.com facebook/cube1113 www.cube1113.com facebook/cube1113

S-ar putea să vă placă și