Documente Academic
Documente Profesional
Documente Cultură
SUPERCRETE is a fourth generation SUPERCRETE Will extend the time span of the
superplasticizer formulated specifically to give high slump twice or longer compare to conventional
range water reduction with retarding effect for hot superplasticizers. However, variations in slump loss
weather construction. At normal 'dosage rates, and setting characteristics are a function of the
SUPERCRETE can produce highly fluid concrete amount of admixture used, material and ambient
with extended workability for placing. temperature, cement characteristics and the mix
SUPERCRETE has been formulated without added design selected. An increase in concrete
chlorides. It is compatible with waterproofing agent temperature will cause an increase in slump loss
and other admixtures. and a decrease in setting time.
Produces "flowing" concrete with controlled The optimum dosage should be determined by site
delay of slump loss and extended workability. trials with the particular raw materials. As a guide,
Reduces segregation & bleeding in the plastic SUPERCRETE is normally used at a dosage range
concrete. of 0.6 litres to 2.0 litres per 100kg of cement.
Reduces porosity and hence permeability of
hardened concrete. (!) PACKAGING AND STORAGE
Reduces concrete placement time and cost.
SUPERCRETE is supplied in 205 litre drums or
When used as a water reducer without cement
bulk delivery. SUPERCRETE should be stored
reduction, it Increases compressive strength by
under shade. The shelf life of SUPERCRETE is 12
70% to 100% depending on dosage and
months in its unopened drums and tanks. Once
concrete mix design.
opened, we recommend that the balance be
consumed within 03 months.
(!) USES
(!) TECHNICAL SERVICE
High performance concrete
Low water/cement concrete mix design The company provides good servicing from a team
High slump, flowable concrete of dedicated specialists in the field. When used in
accordance with its current published directions,
the product will perform as described in this
(!) PROPERTIES
catalogue. Millennium Concrete Technologies will
not be responsible for difficulties caused by other
SUPERCRETE conforms to the requirement of
materials, conditions or inferior workmanship and
ASTM C494 Type G, BS 5075 and SS320: 1987
quality control. We reserve the right to determine
SUPERCRETE can be used to obtain 16% to
the true cause of any difficulty by accepted test
35% water reduction depending on dosage
methods.
used.
(!) COMPATIBILITY
HYPERCRETE is polycarboxylic ether based
advanced superplasticizer which is specially Please seek the advice of Millennium Concrete
developed for Self Compacting Concrete Technologies before being used with other
applications. The product could be used for admixtures.
virtually any type of ready-mix concreting where
the slump retention is important. (!) DIRECTIONS FOR USE
Sulfonic groups of Naphthalene or Melamine The optimum dosage should be determined by site
based admixtures which adsorbed on to the trials with particular raw materials. As a guide
cement particles induce a negative charge and HYPERCRETE is normally used at a dosage 600ml
repulse each other and increase the workability. to 2000ml per IOOkg of cement. However for
With a similar mechanism, but unlike sulfonic specific requirements dosages outside the above
groups, the Iateral chains of the main polymer of could be used.
polycarboxylic ether induce a steric hindrance
(!) PACKAGING AND STORAGE
with strong repulsive force which in tern increase
the workability of the cement paste. HYPERCRETE is supplied in 205 L drums, 1000 L
IBC tanks or in bulks tankers of 2400L
(!) ADVANTAGES
HYPERCRETE has a shelf life of 06 months in its
Make fluid concrete
unopened drums. Once opened, we recommend
Self compacting concrete
that the balance be consumed within 03 weeks.
Longer slump retention.
.
No bleeding & segregation. (!) SAFETY OF HANDLING
Reduce shrinkage and creep.
HYPERCRETE does not contain any hazardous
Reduces porosity and hence permeability of
chemicals and non toxic. But it is recommended
hardened concrete.
that safety glows are used in handling the product.
Rheoplasticity leads to a densely compacted
durable concrete at hardened state. (!) SAFETY OF HANDLING
Substantially reduce the placement cost and
the time. The company provides good servicing from a team
Esthetically attractive surface texture and of dedicated specialists in the field. When used in
sound finish. accordance with its current published directions,
Very high water reduction and thereby low the product will perform as described in this
permeability and shrinkage. catalogue. Millennium Concrete Technologies will
Less pumping pressure and ease of pumping. not be responsible for difficulties caused by other
Helps in hot weather concreting materials , conditions or inferior workmanship and
quality control. We reserve the right to determine
the true cause of any difficulty by accepted test
methods.
(!) COMPATIBILITY
HYPERCRETE R is polycarboxylic ether based
advanced superplasticizer which is specially Please seek the advice of Millennium Concrete
developed for Self Compacting Concrete Technologies before being used with other
applications. The product could be used for admixtures.
virtually any type of ready-mix concreting where
the slump retention is important. (!) DIRECTIONS FOR USE
Sulfonic groups of Naphthalene or Melamine The optimum dosage should be determined by site
based admixtures which adsorbed on to the trials with particular raw materials. As a guide
cement particles induce a negative charge and HYPERCRETE R is normally used at a dosage
repulse each other and increase the workability. 600ml to 1700ml per IOOkg of cement. However
With a similar mechanism, but unlike sulfonic for specific requirements dosages outside the
groups, the Iateral chains of the main polymer of above could be used. Specific Gravity is 1.06 0.03
polycarboxylic ether induce a steric hindrance
(!) PACKAGING AND STORAGE
with strong repulsive force which in tern increase
the workability of the cement paste. HYPERCRETE R is supplied in 205 L drums, 1000 L
IBC tanks or in bulks tankers of 2400L
(!) ADVANTAGES
HYPERCRETE R has a shelf life of 06 months in its
Make fluid concrete unopened drums. Once opened, we recommend
Self Compacting Concrete that the balance be consumed within 03 weeks
Longer slump retention. . (!) SAFETY OF HANDLING
No bleeding & segregation.
Reduce shrinkage and creep. HYPERCRETE R does not contain any hazardous
Reduces porosity and hence permeability of chemicals and non toxic. But it is recommended
hardened concrete. that safety glows are used in handling the product.
Rheoplasticity leads to a densely compacted
durable concrete at hardened state. (!) SAFETY OF HANDLING
Substantially reduce the placement cost and
the time. The company provides good servicing from a team
Esthetically attractive surface texture and of dedicated specialists in the field. When used in
sound finish. accordance with its current published directions,
Very high water reduction and thereby low the product will perform as described in this
permeability and shrinkage. catalogue. Millennium Concrete Technologies will
Less pumping pressure and ease of pumping. not be responsible for difficulties caused by other
Helps in hot weather concreting materials , conditions or inferior workmanship and
quality control. We reserve the right to determine
the true cause of any difficulty by accepted test
methods.
HYPERCRETE PLUS is compatible with all types HYPERCRETE PLUS should be dispensed into the
of cements and other mineral admixtures. pre measured water quantity. This helps the
HYPERCRETE PLUS is free of chlorides and admixture to be mixed homogeneously in the
meets the requirements of ASTM C494 Type A&G concrete. It should not come into contact with dry
and BS 5075. cement or other admixture until they are mixed in
the concrete batch.
Sulfonic groups of Naphthalene or Melamine
based admixtures which adsorbed on to the (!) DOSAGE
cement particles induce a negative charge and The optimum dosage should be determined by site
repulse each other and increase the workability. trials with particular raw materials. As a guide
With a similar mechanism, but unlike sulfonic HYPERCRETE PLUS is normally used at a dosage
groups, the lateral chains of the main polymer of 600m1 to 1200m1 per l00kg of cement. However
polycarboxylic ether induce a steric hindrance for specific requirements dosages outside the
with strong repulsive force which in tern increase above could be used.
the workability of the cement paste.
(!) PACKAGING AND STORAGE
(!) SPECIAL ADVANTAGES HYPERCRETE PLUS is supplied in205L drums or
Specially developed product for concrete in bulks tankers of 2400 L. HYPERCRETE PLUS
produced with 100% manufactured sand. has a shelf life of 12 months in its unopened drums.
Longer slump retention for concrete where Once opened the balance be consumed within 03
maximum slump is less than 200mm. weeks.
Higher concrete density
(!) SAFETY OF HANDLING
Higher strength
(!) ADVANTAGES HYPERCRETE PLUS does not contain any hazardous
chemicals and non toxic. But it is recommended that
Exceptional slump retention properties for all safety glows are used in handling the product.
types of concrete.
No bleeding & segregation. (!) SAFETY OF HANDLING
Reduce shrinkage and creep.
Reduces porosity and hence permeability of The company provides good servicing from a team
hardened concrete. of dedicated specialists in the field. When used in
Rheoplasticity leads to a densely compacted accordance with its current published directions,
durable concrete at hardened state. the product will perform as described in this
Esthetically attractive surface texture and catalogue. Millennium Concrete Technologies will
sound finish. not be responsible for difficulties caused by other
Very high water reduction and thereby low materials , conditions or inferior workmanship and
permeability and shrinkage. quality control. We reserve the right to determine
Less pumping pressure and ease of pumping. the true cause of any difficulty by accepted test
Helps in hot weather concreting methods.
HYPERCRETE PLUS M is compatible with all HYPERCRETE PLUS M should be dispensed into
types of cements and other mineral admixtures. the pre measured water quantity. This helps the
admixture to be mixed homogeneously in the
HYPERCRETE PLUS M is free of chlorides and concrete. It should not come into contact with dry
meets the requirements of ASTM C494 Type A&G cement or other admixture until they are mixed in
and BS 5075. the concrete batch.
HYPERCRETE PLUS SP is compatible with all HYPERCRETE PLUS SP should be dispensed into
types of cements and other mineral admixtures. the pre measured water quantity. This helps the
HYPERCRETE PLUS SP is free of chlorides and admixture to be mixed homogeneously in the
meets the requirements of ASTM C494 Type A&G concrete. It should not come into contact with dry
and BS 5075. cement or other admixture until they are mixed in
the concrete batch.
Sulfonic groups of Naphthalene or Melamine
based admixtures which adsorbed on to the (!) DOSAGE
cement particles induce a negative charge and The optimum dosage should be determined by site
repulse each other and increase the workability. trials with particular raw materials. As a guide
With a similar mechanism, but unlike sulfonic HYPERCRETE PLUS SP is normally used at a
groups, the lateral chains of the main polymer of dosage 600m1 to 1200m1 per l00kg of cement.
polycarboxylic ether induce a steric hindrance However for specific requirements dosages outside
with strong repulsive force which in tern increase the above could be used.
the workability of the cement paste.
(!) PACKAGING AND STORAGE
(!) SPECIAL ADVANTAGES HYPERCRETE PLUS SP is supplied in205L drums
or in bulks tankers of 2400 L. HYPERCRETE PLUS
Suitable to produce self compacting concrete SP has a shelf life of 12 months in its unopened
High initial workability drums. Once opened the balance be consumed
Higher concrete density within 03 weeks.
Higher strength
(!) SAFETY OF HANDLING
(!) ADVANTAGES HYPERCRETE PLUS SP does not contain any
hazardous chemicals and non toxic. But it is
recommended that safety glows are used in handling
Longer slump retention.
the product.
No bleeding & segregation.
Reduce shrinkage and creep.
Reduces porosity and hence permeability of
(!) TECHNICAL SERVICE
hardened concrete.
Rheoplasticity leads to a densely compacted The company provides good servicing from a team
durable concrete at hardened state. of dedicated specialists in the field. When used in
Esthetically attractive surface texture and accordance with its current published directions,
sound finish. the product will perform as described in this
Very high water reduction and thereby low catalogue. Millennium Concrete Technologies will
permeability and shrinkage. not be responsible for difficulties caused by other
Less pumping pressure and ease of pumping. materials , conditions or inferior workmanship and
Helps in hot weather concreting quality control. We reserve the right to determine
the true cause of any difficulty by accepted test
methods.
(!) DOSAGE
The optimum dosage should be determined by site
trials with the particular raw materials. As a guide,
the dosage rate is normally in the range of 1 litre to
3 litres per 100kg of cement.
Admixture VMA is a ready to use liquid based Homogeneous mix Less tendency for bleeding
viscosity modifying admixture, specially developed and segregation
to control the bleeding and segregation of high Improves stability during transportation
workable concrete treated with Polycarboxylic Faster concrete consolidation
Ether based admixtures. Admixture VMA
improves stability and segregation resistance of Admixture VMA assists the concrete placing in
concrete mixes resulting in improved surface the following ways;
quality and aesthetics. Admixture VMA has been Reduction of compaction defects
found to improve plastic properties of self Smoother concrete surface
compacting concrete (SCC) as well as high slump Improves pumpability
conventional concrete mixes and mixes containing Reduced mechanical friction
manufactured sand and/or poorly graded
aggregates aggregates. (!) DOSAGE
Admixture VMA helps stabilize the air void The optimum dosage should be determined by site
systems in freshly mixed and placed concrete and trials with the particular raw materials. As a guide,
increase the overall concrete suitability. Admixture the dosage rate is normally in the range of 1 litre to
VMA is compatible with Hypercrete high range 3 litres per 100kg of cement.
water reducing admixtures and is recommended
for pre-cast and ready-mix concrete applications.
(!) DIRECTIONS FOR USE
Colour: Brown
Admixture VMA does not contain chlorides or any
Specific Gravity: 1.08 0.02
other ingredients which promote the corrosion of
Dosage: 1.0 to 3.0 lit / 100kg
steel. It is therefore suitable for use in reinforced
and pre-stressed concrete structures
(!) FEATURES