Documente Academic
Documente Profesional
Documente Cultură
Please take time to read these safety precautions carefully before connecting your machine to the power supply.
It is essential to follow them and the operating instructions.
First read this entire operating manual. Never place the appliance or power cable on or nearer
To avoid damage, only use capsules designed for this than 50 cm to hot surfaces or open flames.
system with this machine. Never cover the appliance during operation.
Danger of electric shock! Never immerse the appliance Keep children away from the appliance during opera-
in water or any other liquid. tion.
Connect only to a properly grounded power point Only use the appliance in dry rooms.
(230 V) protected by at least a 10 A fuse. Danger of tripping! Do not let the power cable hang
To make sure that the appliance is switched off, switch down.
the power point off and remove the plug from the Pull out the power plug and allow the appliance to cool
power point. down completely before cleaning and or maintenance.
Never clamp or run the power cable over sharp corners To prevent frost damage, do not store the appliance at
or edges. temperatures below 5 C (e.g. in caravans).
Danger of electric shock! Damaged power cables may To prevent damage, never use replacement parts or ac-
only be replaced at the customer service centre. cessories not recommended by the manufacturer.
Danger of electric shock! Never touch the power plug/ Persons, including children, who in view of the level
socket/cable or the appliance with damp or wet hands. of their physical, sensory or mental capacities, or their
Danger of electric shock! Never unplug by pulling the lack of experience or knowledge, are not in a position
power cable out of the power point or machine, always to use the equipment with safety and may not use the
turn off the machine and power point before removing equipment without supervision or instruction from a
the power plug. responsible person.
If you need an extension cable, make sure it is suitable Children should be supervised to ensure that they do
for your appliance (3-pole grounded, 1.5 mm conduc- not play with the appliance.
tor cross-section), and lay the cable to avoid tripping. This appliance is intended to be used in household and
We recommend connecting the appliance via an FI similar applications such as:
circuit-breaker. Consult an electrician or other electrical staff kitchen areas in shops, offices or other working
specialist if in doubt. environments;
Danger of scalding! Never move the appliance during farm houses;
operation! by clients in hotels, motels and other residential type
Never operate the appliance without water. environments;
Danger of burning! Never touch very hot parts of the bed and breakfast environments.
appliance (e.g. brew unit during operations).
Danger of scalding! Do not touch the water jets. Do not use the appliance in case of:
Danger of scalding! Do not move the operating lever faulty operation.
when the appliance is still under pressure making damaged power cable.
coffee. after falling or other damage.
Choose a dry, stable and level support surface for the In such cases immediately have the appliance
appliance, not immediately underneath the power point, checked and repaired if necessary at the customer
and at least 60 cm away from the washbasin and taps. service centre.
Never place the appliance on flammable/fusible sur-
faces or equipment. Always pull out the power plug, in accordance with these
safety instructions, before:
Intended utilization relocating the appliance.
The ESPRESSOTORIA System ADESSO Automatic coffee cleaning or maintenance.
capsule machine is designed only to make espressos and long periods of disuse.
coffee.
Before use
Congratulations!
This ESPRESSOTORIA System ADESSO Automatic coffee Before using your new machine, please read this op-
capsule machine is a first-class product, manufactured erating manual carefully, keep it safe and pass it on to
the next user. For further information please contact
with the greatest care. If you look after it properly it will
reward you with many years of good service. the service and sales centre.
Used
After unpacking, please check that the following parts are included: capsules
Perforated drip container
ESPRESSOTORIA tray cover
Power cable System ADESSO
Automatic coffee
capsule machine
Two-piece
1x water tank lid drip tray
Caution Note
Check that your power supply voltage is the same There can be remaining water in the tank from the
as marked on the machine rating plate (220-240 V). function testing before leaving the factory.
Destroy all the plastic bags to prevent danger to Coffee capsules are not included!
children!
Thoroughly rinse out the water tank with hot water The machine location must meet the following require-
before using for the first time. Clean the capsule coffee ments:
machine using a damp cloth only (see 11. Cleaning the Place the machine on a dry, stable and level surface, not
appliance). directly under the power point. Only use the machine in
a dry room.
Never place the machine or power cable on or nearer
Caution than 50 cm to hot surfaces or open flames.
Danger of tripping! Do not let the power cable Never place the machine nearer than 60 cm to the wash
hang down. basin.
Danger of electric shock! Never clamp or run the If you need an extension cable, make sure it is suitable
power cable over sharp corners or edges or hot for your machine (3-pole grounded, 1.5 mm conductor
surfaces. cross-section).
To make sure that the machine is switched off, Remove the protective foil from the perforated drip tray
switch the power point off and remove the plug cover and insert it in the drip tray.
from the power point.
Danger of scalding: beware of hot water.
Do not operate the machine with an empty water Note
tank. Before using the machine for the first time the
Always pull out the power plug before cleaning the internal piping must be flushed out (for details see: 9.
machine. Flushing machine and internal piping).
Overview
5 6
2
7
8
3
10
1 Water tank lid
2 Water tank
3 Main power switch
4 Power plug socket 13
5 Operating lever
to load the capsules
6 Dispensing button
9
small cup, coffee/hot water
7 Dispensing button
large cup, coffee/hot water
8 Dispensing head 11
for coffee and hot water
9 Drip tray full display 12
10 Perforated drip tray cover
11 Upper drip tray
12 Lower drip tray
with fitting for capsule container
13 Capsule container
for used capsules
Starting up
3. Filling the water tank 4. Starting up / Preheating
Filling without removing Connecting the appliance
the tank Connect the machine to
Turn off the machine. a grounded power point
Remove the water tank lid. by plugging in the power
Fill the tank up to the MAX plug.
mark with cold water (the
maximum is 1 liter).
Replace the lid.
Switching on
Filling by removing the Before turning on the power
water tank switch, make sure that:
Switch off the machine. the operating lever is
Remove the water tank lid. closed.
Lift up the water tank the water tank is full.
holding it by the special the water tank is firmly in
grip (on the outside) and place.
remove it pulling upwards. the drip tray with the
Fill the tank up to the MAX container is completely
mark with cold water (the inserted.
maximum is 1 liter).
Lower the water tank into Turn on the machine with the
place, pushing firmly. main power switch.
Replace the lid.
Preheating
Note After switching on the
Never use distilled water. machine the two coffee dis-
Use only cold tap water. pensing buttons flash in blue
After filling the water tank, and before the next to indicate heating up.
time that coffee is dispensed, press one of the
dispensing buttons, until you obtain a regular flow When heating up is finished
of water from the dispenser (without the capsule). (after approx. 1 min.), the two
Water which has been softened with a commer- coffee dispensing buttons
cially available water filter can be used. Damages remain illuminated in blue. The
caused by wrong handling of the water filter are machine is now ready to use.
not covered by the guarantee.
If the water tank is empty while the machine is
dispensing coffee, the pump will make a very loud
sound. This does not indicate any malfunctioning.
Press one of the dispensing buttons to stop the Note
dispensing of the coffee and the pump is immedi- Before using for the first time and after long periods
ately deactivated. of non-use (for example, vacations) the internal pip-
If no dispensing button is pressed, the pump is au- ing must be flushed out. For details see:
tomatically deactivated after approx. 30 seconds. 9. Flushing machine and internal piping
Making coffee
5. Making coffee 6. After making coffee
Making coffee with this After making coffee the
machine is only possible empty capsule is ejected as
with capsules designed for follows:
this system. Use one capsule Move the operating lever
per cup. completely back to eject
the empty capsule into the
Follow the steps in this order: container. The container
Be sure there is enough holds up to 10 used cap-
water in the tank before sules. It must be emptied
making coffee. regularly.
Move the operating lever
back completely. If you want another cup
Insert a capsule in the of coffee, just insert a new
capsule opening. It auto- capsule and press the cof-
matically falls into the right fee dispensing button (5.
position. Making coffee).
Move the operating lever
completely forward to load
the capsule into the brew-
ing position. Note
Place an empty cup under The capsule may stick in the opening if it has been
the dispenser. there for a long time. If so, open and close the
Press the coffee dispensing operating lever. If the capsule is still blocked, push
buttons: down lightly with a finger.
Small cup: 50 ml Various kinds of coffee (including decaffeinated)
(Espresso default setting) capsules are available.
Large cup: 100 ml
(Coffee default setting) Tip
During the dispensing the Use thick, pre-heated cups for espressos in order
chosen button lighting up. to prevent cooling down too quickly. Cups can be
The automatic switch-off pre-heated by rinsing them with hot water.
device is programmable
(8. Programming the
amount of water).
Caution
Caution
The water coming out of the dispenser is hot!
Danger of scalding!
Cleaning / Storage / Final disposal / Technical data
11. Cleaning the appliance 12. Storage / Final disposal
Coffee machine If the machine will not be
Always ensure the machine used for some time, switch
is switched off and pull it off, switch the power
out the power plug, in point off and pull out
accordance with the safety the power plug from the
instructions, before cleaning power point.
the machine. Store your coffee machine
Never immerse the machine in a dry, dust-free place out of reach of children.
in water or clean it under To avoid frost damage, do not store the machine at
running water. temperatures below 5 C (such as caravans).
Clean the machine with a Important: If the machine is not used for a long time,
damp cloth and allow to dry please follow the cleaning instructions set out in this
afterwards. manual prior to use.
Never use abrasive cleaning
agents or materials. Do not dispose of electrical appliances as un-
sorted municipal waste, use separate collection
facilities. Contact your local government for
information regarding the collection systems
Accessories available.
Clean the water tank,
capsulte container and drip
tray with tepid water and
household detergent.
Never clean it in the dish-
Technical data
washer!
Rated voltage 220-240 V~ 50/60 Hz
3-minutes cleaning mode Rated power 1000 Watt
9 sec.
with cold water Energy saving mode 0.5 Watt
Press both dispensing but- Basic machine dimensions ca. 125 x 387 x 261 mm
tons for 9 Seconds, until the (with depth and height)
button glows green, then
Length of power cable max. 1.50 m
release them.
Weight (without water) ca. 5 kg
Water tank capacity max. 1 l
3-minutes cleaning mode Materials housing/ water plastic
6 sec.
with hot water tank
Press both dispensing but- Radio interference according to
tons for 6 Seconds, until the suppression EU standards
button glows blue, then Compliance CE, GS / RoHS / 5608
release them.
Design or execution changes are reserved in the interest
of technical progress.
Descale
13. Descale
Drinking water varies according to region. The lime par- Descale the machine correctly to prevent damage. So it is
ticles in hard drinking water are deposited as residues in essential to follow these instructions:
the machine and can block the piping and cause damage.
To prevent this, be sure to descale the machine at the very 1. Recommendations: purchase commercially available
least after making 300 to 400 cups of coffee or in any case descaler (descaling liquid), and dilute it following the
if the output falls significantly or, in any case after one or instructions set out by the particular descaling liquid
two months. manufacturer; pour the mixture in the water tank.
2. Make sure the capsule container is empty.
3. Place a large bowl under the dispensing head to col-
1 2 lect the descaling liquid and lime residues and turn
on the power switch (the coffee dispensing displays
flash in blue).
4. As soon as the dispensing displays remain on, press
the dispensing button (small cup). Wait until the
dispensing operation is complete.
5. Turn off the machine with the power switch for about
five minutes and let the descaling fluid take effect.
Then turn on the power switch again and repeat
3 4 points 4 & 5 until the tank is empty.
6. Rinse the water tank well and refill with water. Place
the tank back inside the machine and press the coffee
dispensing button. Press the button again until the
water tank is empty.
5 6
Caution
5 min.
Never clean the machine with vinegar. This causes
damage and makes your coffee taste bad!
Repairs to your machine may only be carried out at the ser- If this troubleshooting guide does not help you solve your
vice centre. Unprofessional repairs and use of non-original problem, please contact your local sales point.
replacement parts can be dangerous for the user. Important: pull out the power plug immediately in case
In case of unprofessional repairs, no liability will be accept- of faults, defects or possible damage to the machine after
ed for resultant damage and the guarantee is invalidated. a fall.
English