Sunteți pe pagina 1din 4

1. ASP stands for...

2. Lean oil that has absorbed heavier hydrocarbon components from a gas stream is
called
3. What kind of test in an oil or gas well to determine its flow capacity at specific
conditions of reservoir and flowing pressures
4. The water and heavy hydrocarbons that condense from the gas stream and accumulate
in the lower points of the flowlines is called
5. In what stage of downhole pumping when the polished rod is going up and the
downhole pump is pumping fluid?
6. The portion of movement of a downhole pump at which the rods are going down and
the downhole pump is being filled with fluid is
7. A perforated tubular attached to the subsurface sucker-rod pump that controls the
entrance of gas is called
8. A multiphase flow regime in which the lighter fluid flows in the center of the pipe,
and the heavier fluid is contained in a thin film on the pipe wall is called
9. Crude oil with oAPI more than 40 is called..
10. FWKO stands for
11. A device with blades inserted in pipeline for cleaning purposes is..
12. In sucker-rod pumping, a situation that occurs when the stroke length at the downhole
pump is shorter than the surface stroke length is called
13. in downhole pumping operations, a condition that occurs when the stroke length at the
subsurface sucker-rod pump is longer than the surface stroke length (polished rod) is
called
14. What kind of test we do if we want to establish the rate and pressure at which fluids
can be pumped into the treatment target without fracturing the formation?
15. The formation of liquid hydrocarbons in a gas reservoir as the pressure in the
reservoir decreases below dew point pressure during production...
16. What instrument records the flow rate of gas through a pipeline?
17. What kind of test to determine well flow capacity at specific reservoir condition ?
18. Mention three kind of well stimulation ?
19. This technique is a technique for measuring the effect of pits and holes in the inner
wall of a casing on a high-frequency electrical signal induced in the casing. What
technique of measurement is it?
20. A perforated tubular attached to the subsurface of sucker rod pump that controls the
entrance of gas is called...
21. An artificial-lift system that operates using a downhole pump is called
22. A condition in downhole pumping operation that occurs when the stroke length at the
subsurface sucker rod pump is longer that surface stroke length (polished rod) is
called
23. The theoretical minimum fluid velocity required to initiate spinner rotation in a
spinner flow meter is
24. In the context of spinner flow meters, the apparent fluid speed measured by the
spinner as the tool is moved up and down the well is called
25. If we want to measure fluid velocity in a production well and also the transit time of a
disturbance between two sensors separated by a fixed distance, what device do we
have to use?
26. A device for measuring in-situ the velocity of fluid flow in a production or injection
well in which the total fluid flow is diverted to pass over an impeller, or spinner is
called
27. A type of artificial lift that uses a rotor and strator is...
28. A process to remove contaminants like H2S and CO2 using amine solution is called...
29. Kind of EOR in which using inert gas like N2 to dissolve oil is called...
30. What is flash point ?
31. Mention two functions of EOR ?
32. The partial pressure of a gas in a mixture of gases is defined as the pressure that the
gas would exert if it alone were present at the same temperature and volume as the
mixture. If the ideal gas law applies, which law states that the total partial pressure of
a mixture is equal to the sum of the partial pressures?
33. A phenomenon that occurs when gas enters the subsurface sucker-rod pump. After
the downstroke begins, the compressed gas reaches the pressure needed to open the
traveling valve before the traveling valve reaches liquid
34. A device used to collect small liquid droplets (moisture or hydrocarbons) from the gas
stream before it leaves the separator
35. Explain about phase diagram
36. Natural gas that contains less methane
37. The burning of unwanted gas through a pipe, used when there is no way to transport
the gas to market and the operator cannot use the gas for another purpose.its called?
38. Mention three kinds of acidizing
39. Curve thats obtained after doing deliverability test is...
40. An electric downhole pump used in heavy oil production that is designed with vane
and fin configurations to accommodate frictional losses and pump efficiencies caused
by heavy oil viscosity.
41. In a gradiomanometer tool, the pressure difference observed when the fluid velocity
opposite the upper pressure sensor differs from that across the lower pressure sensor.
42. The change in temperature observed when a gas expands while flowing through a
restriction without any heat entering or leaving the system is phenomenon called..
43. The temperature at which liquid condenses from a gas..
44. Multiphase production in long flowlines produces intermittent quantities of liquid that
are too large for normal separators to handle. The liquid is diverted to a large vessel
for temporary storage. What is the name for these vessels?
45. Specify the range of degrees API for Heavy oil ?
46. The lowest temperature (in F or C) at which a liquid remains flowable (meaning it
still behaves as a fluid). Is the definision of?
47. What is the composition of LPG ?
48. Mention three types of oil?
49. Classifications of crude oil from North Sea, which the sulfur content is 0.36%. The
API gravity is around 38.5 degrees. It's called?
50. A cylindrical or spherical vessel used to separate oil, gas and water from the total
fluid stream produced by a well. Separators can be either horizontal or vertical. Is the
definition of?

ANSWER
1. Alkaline Surfactant Polimer
2. Rich oil
3. Deliverability test
4. Drip
5. Upstroke
6. downstroke
7. Gas anchor
8. Annular flow
9. Volatile
10. Free water knock out
11. Pig
12. Undertravel
13. Overtravel
14. Injectivity test
15. Orifice meter
16. Retrogade Condensation
17. Deliverability test
18. Acidizing, explosive fracturing, hydraulic fracturing
19. Eddy-current measurement
20. Gas Anchor
21. Hydraulic pumping
22. Overtravel
23. By pass velocity
24. Effective velocity
25. Cross correlation flow meter
26. Diverter flow meter
27. PCP
28. Sweetening
29. Miscible Gas Drive
30. A point in which liquid change state into vapor thats ready to explode or combust
31. Reduce viscosity, reducy density by making substance miscible with oil
32. Daltons law
33. Gas interference
34. Mist Extractor
35. Diagram about phase of oil related to pressure and temperature...
36. Wet gas
37. Flare
38. Matrix acidizing, acid fracturing, acid wash
39. IPR (Inflow performance relationship)
40. ESP
41. Kinetic effect
42. Joule Thompson Effect
43. Dew point
44. Slug Catcher
45. < 22,3oAPI
46. Pour Point
47. Propane and butane
48. Parafin, naphtane, aromatic
49. Brent Crude
50. Separator

S-ar putea să vă placă și