0 evaluări0% au considerat acest document util (0 voturi)
63 vizualizări1 pagină
The document describes how to make an explosive device using readily available materials like Vaseline and ETN crystals. It provides instructions for removing the capacitor from a microwave and wiring it to a high voltage generator and switch in order to detonate the explosive in a controlled manner. The author warns of the danger of the high voltage circuit and advises readers to take safety precautions when handling it.
Descriere originală:
I don't know what this is. So don't ask me what this is.
The document describes how to make an explosive device using readily available materials like Vaseline and ETN crystals. It provides instructions for removing the capacitor from a microwave and wiring it to a high voltage generator and switch in order to detonate the explosive in a controlled manner. The author warns of the danger of the high voltage circuit and advises readers to take safety precautions when handling it.
The document describes how to make an explosive device using readily available materials like Vaseline and ETN crystals. It provides instructions for removing the capacitor from a microwave and wiring it to a high voltage generator and switch in order to detonate the explosive in a controlled manner. The author warns of the danger of the high voltage circuit and advises readers to take safety precautions when handling it.
Vaseline is a readily available plasticizer for ETN.
That would be the simplest way
for the average person to make an equivalent of C4. In order to detonate this substance in a controlled manner via a high voltage discharge: -Purchase a microwave, take out the capacitor and remove the capacitor's internal resistor. There are online guides for doing this. -Tie the capacitor leads together. If the capacitor is charged and the leads are not tied, you will be fatally electrocuted if you touch the leads. -Purchase some 2 gauge wire for discharge leads. -Wire the capacitor in parallel with the discharge leads, a switch and a high voltage step-up generator (Little gizmo that steps up input voltage from ~6 V to ~5 kV. Found on ebay) and power supply. -Drill through the side of a small plastic tube (Like a pen body) and secure the discharge leads to either side -Stuff the tube with ETN crystals. Don't pack the crystals too tightly. -Detonate by actuating the switch after charging the capacitor. -There are many options available for which type of high-voltage switch to use. Default to the safest one.
I implore anyone reading this to be as safe as possible around the capacitor
circuit. The explosives I've described are relatively insensitive and will probably only blow your fingers off in the event of an accident. This circuit could kill you in an instant.