Documente Academic
Documente Profesional
Documente Cultură
Website: www.ijetae.com (ISSN 2250-2459, ISO 9001:2008 Certified Journal, Volume 5, Issue 5, May 2015)
173
International Journal of Emerging Technology and Advanced Engineering
Website: www.ijetae.com (ISSN 2250-2459, ISO 9001:2008 Certified Journal, Volume 5, Issue 5, May 2015)
IV. DETAILS O F COLUMN SPECIMENS The used element is capable of plastic deformation,
Length of all Column Specimens =3200mm cracking in three orthogonal directions, and crushing [9],
Cross Section of all column specimen=300mm×300mm [10].
TABLE I
DETAILS OF COLUMN SPECIMENS
174
International Journal of Emerging Technology and Advanced Engineering
Website: www.ijetae.com (ISSN 2250-2459, ISO 9001:2008 Certified Journal, Volume 5, Issue 5, May 2015)
TABLE III
INPUT DATA AS PER ACI CODE
4.1: IS 456:2000
TABLE IV
INPUT DATA AS PER EGYPTIAN CODE
TABLE V
INPUT DATA AS PER BS 8110 CODE
4.3: BS CODE
Figure 4: Stress-Strain Curves for Concrete as per various codes
5.1: IS 456:2000
175
International Journal of Emerging Technology and Advanced Engineering
Website: www.ijetae.com (ISSN 2250-2459, ISO 9001:2008 Certified Journal, Volume 5, Issue 5, May 2015)
VII. LOADINGS
The parametric studies included in this investigation
are the reinforcement ratios and reinforcement types, and
the characteristic compressive strength of concrete,
ultimate load bearing capacity etc. Table VI shows the
ultimate loads on columns using ultimate load carrying
capacity formula on the basis of different codes [11],
[12], [13], [14].
TABLE VI
5.3: BS CODE
ULTIMATE LOAD ON COLUMN (KN)
Figure 5: Stress-Strain Curve for Steel as per various codes
6.2: BS CODE
176
International Journal of Emerging Technology and Advanced Engineering
Website: www.ijetae.com (ISSN 2250-2459, ISO 9001:2008 Certified Journal, Volume 5, Issue 5, May 2015)
TABLE VII 8.3 Non Linear Analysis:
ANSYS RESULTS FOR DEFORMATION (LINEAR ANALYSIS)
Table X shows analytical results of deformations using
ANSYS and also shows the comparison of deformations
using Steel and GFRP as a reinforcement as per various
codes. The analysis results are shown graphically in
figure 11 to figure 14.
TABLE X
ANSYS RESULTS FOR DEFORMATION (NON LINEAR
ANALYSIS)
177
International Journal of Emerging Technology and Advanced Engineering
Website: www.ijetae.com (ISSN 2250-2459, ISO 9001:2008 Certified Journal, Volume 5, Issue 5, May 2015)
179