Documente Academic
Documente Profesional
Documente Cultură
Question 1
When a control valve is installed in a process with where the di erential pressure (drop
increasing ow, the best trim characteristic to choose for the valve would be:
(A) Ported
(B) Quick-opening
(C) Equal percentage
(D) Linear
(E) Anti-cavitation
Answer : C
Question 2
The correct identities of the four control valve types shown below are (in order from left to r
Answer : C
Question 3
ALL ANIMATION BASICS MEASUREMENT CONTROL SYSTEMS Q&A
ELECTRO
https://instrumentationtools.com/control-valves-multiple-choice-questions/#.WoZq966WbIU 2/11
2/16/2018 Control Valves Multiple Choice Questions Instrumentation Tools
An air-to-open control valve assembly may be formed with which of these actuator/valve bo
Answer : D
Question 4
Calculate the necessary Cv rating for a liquid service control valve, given a pressure drop o
and a maximum ow rate of 140 GPM. Assume there will be no ashing or choked ow thro
(A) 0.1319
(B) 32.58
(C) 7.583
(D) 2585
(E) 601.5
Answer : B
Question 5
Answer : B
ALL ANIMATION
Question 6
BASICS MEASUREMENT CONTROL SYSTEMS Q&A
ELECTRO
https://instrumentationtools.com/control-valves-multiple-choice-questions/#.WoZq966WbIU 3/11
2/16/2018 Control Valves Multiple Choice Questions Instrumentation Tools
Answer : D
Question 7
The de nition of split range control valves implies that they are . . .
Answer : E
Question 8
Dual-ported globe valves typically enjoy the following advantage over single-ported globe va
https://instrumentationtools.com/control-valves-multiple-choice-questions/#.WoZq966WbIU 4/11
2/16/2018 Control Valves Multiple Choice Questions Instrumentation Tools
Answer : A
Question 9
Answer : E
Question 10
The proper “fail safe” status of a control valve should always be dictated by:
Answer : E
Print
ALL Facebook
ANIMATION Twitter
BASICS MEASUREMENT Email
CONTROLMore 66
SYSTEMS Q&A
ELECTRO
https://instrumentationtools.com/control-valves-multiple-choice-questions/#.WoZq966WbIU 5/11