Sunteți pe pagina 1din 14

Some Practical Aspects of Ship

Launching
Part 1. Starting and Checking
BY .HARRISON B. ANDREWS, I~/~EMBER2

In the first part of this paper it is proposed to STARTING


dwell briefly upon two aspects of launching--the Before any new ship construction may be
engineering and preparations required to assure, started, several launching problems present them-
as far as possible, an unaided start and the engi- selves for consideration. The decisions reached
neering and set-up required for checking the travel, at that early stage tend to allay the fears or to
without regard to studies of pivoting, way-end increase the anxiety on launching day of the per-
pressure, stability, etc. sons responsible for the launching operations.
1 Paper presented before the October 1945 meeting of the New The two most important figures to be settled
England Section of The Society of Naval Architects and Marine
Engineers. for the successful start of a vessel at launching are
2 Engineer, Bethlehem Steel Company, Shipbuilding Division,
Quincy, Mass. the slope of the ground ways and the pressure on

3.2

3.'0
I I A~rcraff Carrier
2.8 \ Z Bafflesh~p
3 Cruiser
2.6 \ 4 Pass.torso Ship
5 Cargo Ship
6"
to 2.4
o)
O.
2.2
~%- 2 0 ~ ' ~ , IO Trawler
0:2.0

u) 1.8 ....

to
I-
o. 1.6
-6 -Z22ZL~....~......_ ,W ~-=-
c 1.4

1.2

1.0

0.8
0.45 0.50 0.55 0.60 0.65 0.-/0 0.'/5 O.BO 0.B5 0.90 0.95 LO0
5lope o4 Ways, S~ In. Per" Ft-.
Fro. 1
424
SHIP LAUNCHING 425

th~ grease. The slope of the ground ways affects The figures of grease pressure mentioned are not
the elevation of the vessel on the slip during con- hard and fast limits, as m a n y launehings have
struction and consequently it must be determined been performed successfully with pressures both
before construction has started. Since it is ad- above 2.25 and below 1.75 tons per square foot.
vantageous for the construction departments to Since in all cases the object is to set up the launch-
build a vessel close to the ground, there is always ing arrangements for a good start, and the pub-
present, in the early stages, the tendency to sacri- lished figures of pressure and slope in connection
fice starting slope for lower elevations. with slow starts are obviously few, it is difficult to
Good launching practice indicates a fairly defi- obtain data for the lower limits of pressure.
nite relation between the slope of the ways and the L a b o r a t o r y test curves are available from the
pressure on the grease. This relationship is il-- various grease manufacturers, and also from tests
lustrated broadly in Fig. 1. All of the points at some shipyards, showing coefficients of sliding
shown are actual figures of typical vessels launched friction plotted against grease pressure b u t it is
under the observation of the author. The dotted difficult to translate the results from the small-
lines indicate the upper and lower limits of typical scale test equipment into the much larger and
launching practice and were chosen primarily to rougher actual launching set-up.
define a band encompassing most of the past suc- A ship's launching justifiably m a y be classed
cessful launehings observed b y the author. The equally as an art as a science. Despite the ac-
band is wide and appears to allow considerable counting for all known factors and identical con-
spread in pressure for a fixed slope. I t is none too ditions for two launehings, marked differences in
wide, however, to allow for the variation in es- performance often occur. This is notably true in
timated pressure before launching. Present ship starting. For example, instances can be cited
construction methods develop large assembly sec- when, with all conditions constant except temper-
tions and the difference in launching grease pres- ature, the launching taking placed in the lower
sure caused b y one or two large superstructure as- temperature will be normal while t h a t at the
semblies being on or off the ship can be quite no- higher temperature m a y be sluggish in starting or
ticeable. the ship even m a y refuse to move. This does not
I t would be quite simple to solve the starting discredit the t r e a t m e n t of the problem as a sci-
question in a n y launching b y setting up the ground entific one but simply urges the addition of a
ways with a high slope and letting the pressure grain of salt to the result and makes the final suc-
come what it may. This obviously is not the solu- cess of the launching more savory.
tion in the case of vessels of the length of our pres- Additional considerations of the starting prob-
ent airplane carriers, where the bow of the vessel lem ar~ largely in the hands of the carpenters who
would be out of sight on foggy days. On the construct the launching cradle. The ground ways
other hand, a trawler could not be set up sensibly should be alined closely to the required declivity;
on a low slope, relying upon the pressure for a good the grease should be applied carefully; the cradle
start, since the width of ways would be too narrow should be constructed so as to o b t a i n the best
for reasonable cradle construction. possible distribution of load over the grease; and
The shipyards of this country have accepted the wedging up and removal of shoring and block-
mineral base greases almost unanimously with ing should be carried out according to schedule, so
verv few exceptions such as the one in the South as to lower the cradle as evenly as possible on to
which is quoted as using bananas. All of the vari- the grease surface.
ous companies handling launching greases have The care taken to aline the ground ways prop-
contributed to the i m p r o v e m e n t of the product so erly becomes particularly i m p o r t a n t when four
t h a t the shipbuilder now can rely on the published launching ways are used. Although the use of two
data without hesitation. N o t too m a n y years launching ways is almost universal, even in the
ago in this country, and still t o d a y in some Euro- cases of the Queen Mary and Normandie where the
pean yards, the carpenter has formulated the launching weights, including cradles, were 36,700
launching greases and, as with all good chefs, tons and 27,660 tons, respectively, several four-
added his own special touch or words of sorcery to way launchings have been carried out in recent
the brew. years. Among these were the recent launehings
T o d a y we accept the fact t h a t the base coat of our new Iowa and South Dakota classes of bat-
should give a hard smooth surface capable of tleships, when four ways were used because of the
withstanding the pressures at pivoting, and t h a t high launching weight concentrated in a relatively
the slip coat should give constant low coefficients short length. The custom in the Netherlands has
of friction, without squeezing out, under pressures been to concentrate the load on a centerline way
of 1.75 to 2.25 tons per square foot. with secondary ways outboard for stability.
426 SHIP LAUNCHING

With the accomplishment of wedging-up and the movement, while at the other end rope lashir]gs
removal of shoring and blocking, the weight of the made it fast by applying force in the direction of
vessel is transferred to the sliding ways through the force applied by the ship's weight down the
the cradle and poppets. Referring to Fig. 2, the ways. Another similar method is employed at
components F1 of the total weight of the ship and present in the side-launchings on the Great

4,

FIG. 2
Slldi~g Way( )Sole ?la¢e

sliding structure down the ways is opposed, upon


release, only by the force of friction F~. Now
F1 = W s i n 0
and FIG. 4

Fa = f t V c o s O

where f is the coefficient of friction. Lakes. Here, again, use is made of a beam as a
For the vessel to move, W sin 0 must be greater lever with the outboard end lashed to a deadman.
than f W cos 0; t h a t is, tan O, the starting slope, In both eases the release of the ship is effected by
must be greater than f, the coefficient of friction. simultaneously cutting all the rope lashings. In
Before release, this net force down the ways of some instances this is accomplished b y men with
W sin 0 -- f W cos 0 is neutralized b y the triggers or axes. In others a guillotine arrangement is used.
other holding and releasing mechanism, of which T h a t used in the Great Lakes side-launchings
there are several types. consists of pneumatically operated knives, all con-
netted to the same air line.
A second method of holding, still in use for
launchings of moderate weight, is that which em-
ploys a wooden "saw piece" or a steel "sole plate"
to tie the forward ends of the sliding ways to the
stationary ground ways. This is illustrated in
Ground Wa Fig. 4. The release is brought about b y cutting at
equal rates the two "saw pieces" or "sole plates."
Fulcrum Pile 9 Ultimately these ties should break and the area
through the breaks provides a straightforward
-~----Timber Lever
means of measuring the net starting force down
Deo4man the ways. However, high tensile stresses are set
up in the forward ends of the sliding ways and
the loading cannot be distributed evenly through-
out the length of the sliding ways nor over more
than two such holding units.
FI~. 3
In universal use, at present, for launchings of
any large magnitude is the system employing
Among the earliest and simplest holding and groupings of hydraulic or mechanical triggers ar-
releasing devices are those using a few pieces of ranged in such numbers, and so spaced, as to limit
heavy timber and rope lashing. One device, the local loadings in the sliding ways or on the
shown in Fig. 3, was a type of dog shore and con- triggers. Both types of trigger have been used in
sisted of a large beam laid at right angles to the recent years, the hydraulic (Fig. 5) now having
ways on each side of the ship. Some distance been replaced by the mechanical in many yards,
along the beam, on the water side, was a pile although overall usage indicates about equal favor
driven into the ground for a fulcrum. One end for both. The holding effect of the hydraulic trig-
was applied to the sliding way to prevent its ger is brought about usually through the appliea-
SHIP LAUNCHING 427

tion of force from an hydraulic ram to one end of a CHECKING


lever whose other end prevents movement of the While sliding down the ways and until entry
sliding ways. Removal of hydraulic pressure into the water, the two previously mentioned
through the handling of one valve at a central forces are acting upon the ship and sliding struc-
control station releases all triggers together. ture: (1) Its weight, bringing about a component
The adoption of the use of mechanical triggers of force acting down the ways, and (2), the force of
at the Quincy Yard of the Bethlehem Steel Com- friction between the sliding and ground ways act-
pany was brought about when new contracts re- ing in a reverse direction. As soon as the cradle
quired the building of additional means of holding enters the water, a third force, that of water re-
sistance, is introduced which also acts to retard
the ship's velocity and to limit its travel. T h e
5hoe third, and final, phase of the ship's travel begins
as the vessel floats or drops off the way ends.
From this point on, there is no component of force
down the ways in effect and the ship comes to rest
when its kinetic energy is entirely dissipated b y the
water resistance alone or, if space is limited, it be-
• I '1 ~/./K./,.///,,. I1,11I] 4
comes necessary to add a further resistance so
that the travel, over which work must be done by
the resisting forces, becomes less.
There are, of course, m a n y yards so advanta-
geously situated alongside a clear expanse of deep
~ ~ Preventer water that, once released, the vessels are allowed
to run free until picked up by tugs. Some of the
ka'fch very largest ships, however, have been launched
FIG. 5 in very restricted waterways, such as, for example,
the River Clyde in Scotland. In such cases, unu-
sual precautions must be taken for the ship to re-
and releasing vessels up to 28,000 tons launching main clear of the opposite shore. In the case of
weight. At t h a t time, consideration was given to the Clyde, the slipways are laid out at an angle of
the possibility of designing a trigger radically dif- about 30 degrees to the shoreline, considerabIe
ferent from the hydraulic type which was being dredging is necessary and checking devices are
used, in forms generally similar and varying only used.
in detail, in all of the large shipyards in the United Checking devices have taken several forms and
States. have been used in m a n y combinations. The sim-
Since the shipbuilding program then indicated a plest type is a mask hung at the after end of the
great m a n y vessels to be built, and of varying ship so as to present a plane surface at right angles
types, it was thought advisable to design the trig- to the line of motion and thereby increase the
gers so t h a t they could be used in pairs, one pair water resistance. Only a relatively small gain is
for vessels up to 10,000 tons launching weight, added, however, and this is not easily estimated
two pairs for vessels between 10,000 and 20,000 without model experiments. Furthermore, water
tons, and three pairs for vessels from 20,000 to 30,- resistance varies with the square of the speed and
000 tons launching weight. This system also does not remain a substantial, effective force.
would provide the advantage of distributing the Theoretically, then, the ship will keep moving
holding power along the length of the cradle in- into infinity unless other forces are brought to
stead of concentrating it at the one trigger loca- bear.
tion, as had been the practice previously. Where a more positive method of control is de-
The design problem then became one to produce sired and space is still not severely limited, an-
a workable trigger, simple in installation, as fool- chors may be dropped when the vessel is water
proof as possible, to allow release in a limited borne.
vertical clearance, to be applicable to various Among the devices used in Germany on the
types of vessels and, when used in groups, to make Kaiser Wilhelm II, some time prior to 1903, was a
possible a simultaneous release. These conditions wedge friction brake consisting of a wedge-shaped
led to the adoption of mechanical triggers capable log made fast to the ship b y lines so that the log
of release electrically or manually. The details of was pulled against friction through a tightly fit-
the design are deseribed in the second part of this ting trough of steel bands. No other instance of its
paper. use is known to the author.
428 SHIP LAUNCHING

There is, further, the device which employs The other common method of checking at
rope stops. Here a length of chain is made fast launching, using chain drags, consists of placing
to a stationary point on land and another is made the chain on the slipway alongside the vessel to
fast to the ship. Between them run rope lashings offer additional resistance while the ship moves in
which are spaced so as.to break at intervals in the a straight-line path, and of making the piles fast
travel of the one chain relative to the other. The to the vessel with wire drag ropes attached near
travel of the ship during launching brings this the bow of the vessel.
about and the breaking of the rope lashings serves The factors involved in the solution of a check-
to decrease the ship's speed and to restrict its ing p r o b l e m u s i n g either the slewing or the
travel. straight-line system are the same. These factors
At the launching of a battleship in 1919, hy- include the weight of the ship and cradle, the depth
draulic rope brakes were used for checking. These of water over the way-ends, the coefficient of fric-
were made up of a mated pair of steel shoes tion of the grease, the water resistance coefficients
grooved to take a wire-rope cable fixed to the for- and the coefficient of friction of chain on the drag
ward end of the ship. T h e y were mounted on the surface.
ground, under the bow of the ship, and so fitted The launching calculations performed for pro-
with a hydraulic ram as to make it possible to vary ducing the routine launching curves provide the
the pressure between the shoes and thus vary the figures for the first two factors enumerated. The
frictional force on the wire rope running between three coefficients of resistance must be determined
them. Five such brakes were used on each side. experimentally or estimated from the analysis of
The disadvantage of this system of checking is actual launehings.
that it is difficult to gage the pressure to apply and Coefficients of friction of launching grease will
the method requires manual control during a pe- vary somewhat, depending upon the type of
riod of excitement and strain when improper action grease selected. The results of several hundred
is more apt to be taken and signals are more apt launchings within the author's experience have
to be confused. shown, however, that the variation in coefficient
The most common checking methods in use to- of grease friction is small. The figures commonly
day for launching vessels in restricted waters are used will vary from 0.0175 to 0.025.
those which lend themselves most readily to direct Data obtained from experiment for coefficients
calculation. The prevalence of the moment is on of chain drag friction have been questioned, since
the side of some form of the chain drag system. it is difficult to conduct the tests with high enough
When the initial checking calculations indicate velocities to compare with the actual launching
that the length of the launching basin is not suffi- conditions. Experimental data have been used,
cient to allow a free run but is long enough to allow however, and the overall results of the launchings
the water resistance to act for a relatively long have indicated that these data are well within the
time, slewing methods are generally the most prac- range of accuracy of the launching calculations.
tical, since the amount of chain required can be Typical data for coefficients of drag friction for
kept to a minimum. In general, any method of .various surfaces are:
slewing involves placing of chain piles or other Hard-packed dirt 0.65-0.75
weights in the water, clear of the building slip, Smooth concrete 0.35-0.45
and making them fast to the stern of the vessel Sand on concrete 0.65-0.70
with wire drag ropes of predetermined length. Although some model experimental data are
When the vessel is waterborne during launching, available for water resistance coefficients, most
the resistance of the chain pulling along the bot- shipyards must rely on the data obtained from ac-
tom of the launching basin slews the vessel from tual launching analysis.
its initial line of motion.
ANALYSIS
The method of slewing, using chain drags, has
been used successfully in recent years in the The analysis of results of a launching is carried
launching of some of the heaviest vessels con- out as a check on the estimates made in the design
structed in this country. Previous to the launch- stage and equally to determine the values of water
ing of one of the Iowa-class battleships, model ex- resistance and coefficients of grease and drag fric-
periments were conducted to ascertain the slewing tion.
effect of the chain drags with several coefficients The basis for such an analysis is an accurate
of drag friction. The use of models in this con- record of time and distance obtained b y any one of
nection proved to be a valuable aid in predicting several timing methods or an accurate record of
the stopped position of the vessel and in determin- acceleration as measured b y means of an acceler-
ing the amount and distribution of chain used. ometer. Since acceleration is the key figure in
SHIP LAUNCHING 429

300

200

~00
o
t'-
+
¢)
0
0,,o

I00

ZOO

900 800 700 600 500 400 300 ~_00 I00 0


T r a v e l - Fe~+
FIG. 6

the launching analysis, the aceelerometer method Fa= F I - F


eliminates the necessity for successive differentia- and the coeffÉcientof grease friction f is
tions of the time-distance curve.
The force diagram (Fig. 6) shows graphically F~
the relative amounts of work done b y each and f (W - B) cos 0
their interrelation. T h e work done b y the ship's or
weight during the launching is represented b y the
area under the circumscribing trapezium. T h e f = tan 0 - a
g cos 0
formula for the boundary curve is W sin 0, where
W is the total weight of ship and cradle and 0 is The value of the coefficient of drag friction can
the angle of slope of the ways. The resisting be found in a similar manner b y utilizing the end
force attributed to buoyancy is B sin 0, so t h a t the spot of the force diagram. At t h a t point the
actual force acting down the ways is (W -- B) sin forces of grease resistance and water resistance
0, B being the buoyancy. have become zero and
Grease friction is expressed in the form f (W -- ~=F
B) cos 0. The accurate value of W is determined
after the launching from a reading of the ship's then
drafts, while f, the coefficient of friction, is found
F5 = f ' w = F
in the following way.
With the acceleration and the weight of the ship where f ' is the coefficient of drag friction, and w
and cradle known, the resultant'force F can be de- is the weight of drags.
termined from the formula
The last of the unknowns, and the most im-
F = ~a = -
Wa p o r t a n t from the standpoint of valuable data, is
g the water resistance coefficient.
Referring to Fig. 6, for the portion of the ship's The value of the force of water resistance #'4 can
travel from the start until the cradle enters the be found from the formula
water F = F,--F2-Fa--F4--F6
450 SHIP LAUNCHING

1400

1200
----- cargo Pass.Sh{p / " ~
Mrcra~ C~rrier /,~.
Desfroy~r ,-,
10O0 ..... Cruiser
-l~ L NN

800
2 ~I 1"/

o 600 . ~"

40o /'" J

N "/ ~-'i:

/F
0
o Io Z0 ao go 50 60 70 8o g0 Ioo
Per Cen~rof To~olBuoyancy
FIG. 7

since at this stage of the analysis all of the other Curves showing the value of C for different
forces are known. types of vessels taken from the analysis of actual
When the force of water resistance is denoted as launchings are shown in Fig. 7 plotted against per
F4 = K v ~ cent of total buoyancy.
it has been shown t h a t the coefficient K may be In the use of the curves of the coefficient C, the
expressed as assumption can be made that C remains constant
B2/, between float-off and the stopped position. The
C analysis of many launching results has shown that
where C is a value varying with the type of vessel the error in this assumption is small and will have
and the buoyancy. relatively little effect on the overall results.

Part 2. Mechanical Triggers


BY ARCHER /V[. NICKERSON, IR., ASSOCIATE ~[EiViBER 3

Mechanical triggers of the multiple-lever type launchings has not been customary; {n fact, at
have been used in foreign shipyards for m a n y the time of the trigger developments to be de-
years. Their use in American yards for end- scribed, which began in the spring of 1940, there
was virtually nothing similar in American prac-
3 Engineer, Bethlehem Steel Company, Shipbuilding Division,
Quincy, Mass. tice for end-launchings of larger vessels with the
SHIP LAUNCHING 451

exception of the lever and hydraulic r a m systems trigger load lever to clear the sliding ways
known as hydraulic triggers, mentioned in P a r t 1 p r o m p t l y upon release; in others, the trigger de-
of this paper and one type of which is illustrated sign has been complicated b y the application of
in Fig. 5. I t is believed therefore t h a t an account supplementary air-operated booster rams to force
of the development and use of three successful the main levers away from the cradle. Finally, the
mechanical trigger designs, with which the authors hydraulic fluid must be of an anti-freezing type for
are familiar, m a y be of general interest. I t is winter-time launchings and there m u s t be a suf-
elected t h a t this be an outline of what was done ficient margin of volume on hand to allow for an
rather than a treatise on how such triggers should amount of leakage difficult to predict. After
be designed, for while the principles m a y be the weighing these facts against the probable ad-
same the launching conditions will v a r y between vantages and possible deficiencies of mechanical
shipyards and for this reason no standard trigger trigger operation, a decision was made to proceed
type can be recommended. Figs. 8 to [5 inclusive with the mechanical type in a design exceeding the
are diagrammatic. No details are given as their capacity of anything at hand in the shipyard at
development followed accepted engineering prac- the time.
tice. A precedent for this design was the type of trig-
Mechanical and hydraulic launching triggers ger used in launching the British steamship Queen
offer a number of advantages over a n y other type
of holding device. A multiplicity of such triggers Firsl L e v e r ~
can be arranged readily for simultaneous release
and therefore can be used for safely holding the Tricjger .. f-'!-'" ~ ] t
Frome i ~\'< }
largest vessels. The fastenings between wood and
the steel trigger frames can be made dependable. ', ~Second Lever __~Releasing 6ear
The force down the ways can be well distributed I I
i i "
over the cradle and ground ways and in large ], We~cJh÷
measure can be transmitted to the wood in com-
pression. B y comparison, the holding of a hull
at the forward end of the cradle concentrates
loads on members least able to withstand them.
~ 1Wooa Founda'Hon 1
O-uadran~

When successive launchings of the same type of FIG. 8.--LAUNCHING TRIGGER--SET POSITION
ship from one slipway are required b y a quantity
building program, the state of fastenings trans-
mitting loads in shear and in tension from the for-
~Hgger . ""
ward end of the sliding ways to the ground ways
is sometimes in doubt, because of a tendency to-
ward gradual failure of the wooden members with /XSec0nd \ \/--gaelec~ing 6eor
repeated loadings.
The use of the hydraulic trigger is subject to
some disadvantages which can be serious. Pip-
ing joints m a y fail as pressure is developed in the
hydraulic system. The r a m packing m a y start to Wood "-"-L~/7 I /
leak at an embarrassing time in the schedule of Foundv,~ion ~ ', ' ,"
prelaunching events. Exposed piping and valves We, h~ ~'~'~' /
are subject to possible damage while shores and
blocking material are being removed from the FIG. 9.--LAUNCHING TRIGGER--RELEASED POSITION
hull. In theory, the hydraulic system m a y be
filled and its pressure, as the load comes on the Mary. This is shown in Figs. 8 and 9 and consists
triggers, m a y be taken as a measure of the total of a train of levers, the load being applied to the
load down the ways. In practice, the systems "main lever" and reduced b y the overall mechani-
are often p u m p e d to a pressure well in excess of cal advantage of the system to an a m o u n t which
the a m o u n t anticipated, in order t h a t there will be can be controlled b y the safety quadrant illus-
no question about holding. Hydraulic triggers are trated. T h e trigger is released electrically b y the
sometimes slow in releasing, especially when a action of a solenoid. In the "set" position, a weight
group of triggers m u s t be served b y one relatively in the form of a h a m m e r is suspended b y the sole-
small releasing valve. In some cases this has re- noid latch. The h a m m e r "handle" rides in a slot in
sulted in scuffing of the cradle b y failure of the the quadrant are and, bearing on the upper end of
432 SHIP LAUNCHING

Sa~efy Clip .Releose Lever


Hammer I / SolenoTd -FirsfLever

,/ ", \ _ _ 2 1 , ". . . . . ]
i ~I ~I/_/~u~/Yoke 1 '--[i__. .9"l_ Topof Ground W°~
Trigger
I .~;~',,X~,~.-.~ .L/l r Ind~cafor \ ,/ ,'~', ,~-.q lO.580Lb. F Frame

2
' /

Or°~ L'nk ~ B u ~ ; : ; n ¢ [ Lev'r ~

0 6 12 0 6 IZ
Inches Inches
FIG. 10.--170-TON LAUNCHING TRIGGER--SET POSITION FIG. l l . - - 1 7 0 - T o N LAUNCHING TRIGGER--RELEASED
POSITION

this slot, holds the quadrant in positive engage- of last-minute failure of electrical wiring the trig-
m e n t with the long a r m of the last lever in the gers should at least be "hung-up" in pairs, two of
train, thus preventing its inadvertent release. which would hold until released b y hand or one of
When the solenoid latch is tripped, the h a m m e r which might hold, depending on actual loading, or
swings freely until its handle strikes the other end be forced away from the cradle without jeopardiz-
of the q u a d r a n t slot. T h e impact turns the quad- ing the success of the launch.
r a n t on its axis, permitting the last lever in the A test set-up was made in which each finished
train to fly upward and thereby release the other trigger was bolted to simulated ground ways,
two, the main lever falling away from the struc- given a check for " g r a v i t y " release and load by
tural bearing m e m b e r in the cradle and releasing increments to a total of 340 long tons or 100 per
the ship. Three pairs of these triggers were used cent over the average load anticipated. Other
in this launching, the solenoids being wired in a special tests included separate overloading of the
common electrical circuit. For all practical pur- outside or third lever, simulating trigger load up
poses this arrangement assures simultaneous trig- to the elastic limit of the levers, and checks of the
ger release. releasing mechanisms at this load, wiping contact
T h e release b y gravity of the Queen Mary trig- surfaces between the third lever and its supporting
gers is questionable because the third lever must yoke dry and finally abrading t h e m in a demon-
rise. T h e releasing quadrant is mounted on a sep- stration of adequate h a m m e r energy. The strain
arate structure a p a r t from the ground ways. I t gage shown in Fig. 10 and used for giving a meas-
was felt t h a t this design could be improved upon ure of load on the trigger in terms of the deflection
b y the elimination of these two features, since of the last lever was also calibrated during tile trig-
tile rising lever offers additional resistance to be ger tests. The triggers were released under load
overcome in the event of a sluggish launch, and onto the eccentric safety pins and reset after ro-
the separate support for the holding and release tating the pins b y means of the hand lever pro-
of the last lever is subject to possible damage dur- vided as an integral p a r t of each pin. Following
ing removal of shores and cribbing. The new de- this, they were released under load as in actual
sign therefore was based on a lever and releasing service.
system self-contained in the trigger frame, each T h e first trigger test demonstrated the need of
lever of which was to fall freely upon release. rugged b u t simple wooden buffers shaped to the
T h e resulting arrangement is indicated in Figs. general contour of the levers for good impact
10 and 11. These triggers were planned specifi- load distribution. These had been fitted for the
cally for the launching of U.S.S. 3Iassachusetts and main and second levers. At no load, the release
three pairs were to be used in the set-up. The averaged 2 seconds time from the solenoid action
original load calculation per trigger, based on uni- to clearance of the main lever. Under load, the
form distribution, was 170 long tons. I t was de- release was quite like an explosion and it was im-
cided t h a t the trigger elements should be stressed possible to distinguish the "one-two-three" order
to the elastic limit at 515 tong tons load. The so- of dropping the levers. The outside lever flew
lenoids of each pair were wired in series and the around at great speed and b u t for an intervening
pairs in parallel, for it was desired t h a t in the event plank would have carried away the links and le-
SHIP LAUNCHING 433

.e"
Top of Ground Wmy
C ~/ ~ 41..__!£_~~ "tons
TOp of Ground Way ~ Lb. Trigger~~
Frc~rnet ~
Trigg ~ . ~,
Frome ~1 c~ ~.
t] ! "'-2-
SecondL e v e r / 0(5.
Safe+ypin/ "~,~jxF
~o, r~hLever ~Thlrd Lever
\.%
° tb "%7~. Sccde

0 6 12
Inche~
0 6
]nches
~2 Hook S~ripF -~ FIG. 13.--40-TONLAUNCHINGTRIGGI~R--RI~LBASBD
POSITION
FIG. 12.---40-TON LAUNCHING TRIGGER--NET POSITION

circuits at a n y time up to the m o m e n t of launch.


vers of the releasing mechanism. Under a hull the This voltage was tapped off from the same stor-
stored energy produces much the same effect but, age batteries as used as a current source for the
as the total resilience is less than t h a t of the trig- actual release. In addition, signal lamps were
ger and test frame combination, the lever impact arranged to glow at each trigger when its solenoid
is not as severe. The trigger resilience contributes is energized and at the control panel when each
to a snappy release and a buffer was found essen- trigger is released, the latter actuated b y norm-
tial for arresting the motion of the last lever as ally closed switches which are held open in the
well as t h a t of the other two. "set" position of the levers. Pushbuttons were
The strain gage, eccentric safety pin and release provided for testing these lamps. The main con-
lever latch were additions made to the design trol panel contains the test switches, pushbuttons,
after testing the first trigger. The strain gage was voltmeters, "released" signal lamps and a two-
the result of a suggestion t h a t it would be desir- pole, single-throw master switch with a positive
able to measure the total load down the ways and safety lock in the open position.
determine its general distribution on the indi- In use, a "trigger m a n " is assigned to each trig-
vidual triggers. These gages were not expected to ger for taking strain gage measurements and for
be extremely accurate, b u t they have served well removing the h a m m e r safety clip and outside
as an indication of the percentage load distribu- lever safety pin. An electrician is also on d u t y at
tion. A jacking arrangement was requested to en- each trigger for transmitting readings and instruc-
able a full test of the releasing mechanism up to the tions between the triggGr man and launching log
m o m e n t of launch if desired. The eccentric safety desk b y telephone. Upon removal of all support-
pins worked out very nicely. T h e y are set to be ing material under the hull, the trigger men are
clear of the last lever b y }~6 inch when the hand instructed to remove strain gages, h a m m e r clips
lever is down and to raise the lever }{ 6 inch clear and safety pins in t h a t order and to stow t h e m in
of its supporting yoke when the hand lever is a rack provided for the purpose adjacent to the
turned 180 degrees. T h e y require about 20 log desk. All triggers and these removable parts
pounds on the hand lever to reset the trigger under are numbered and the latter have their assigned
full test load. The release lever latch was applied places in the rack. When the rack is filled, those
as a safety measure "to hold the supporting yoke in charge know t h a t the triggers are clear. After
clear of the last lever and to prevent automatic a warning signal to the sponsor, the triggers are
resetting of the trigger in the event of a sluggish released b y the single act of closing the master
release. switch. When the "release" signal lamps glow,
Several wiring arrangements are possible for the master switch is again opened to de-energize
the releasing solenoids. The fundamental circuit the trigger solenoids.
adopted is described in the foregoing. To this After a "trial trip" in which one pair of triggers
were added a test circuit and switches permitting was used to launch a tanker, the three original
the application of low voltage to each solenoid in pairs were set up under U.S.S. ~llassachusetts,
order to check the voltage drops in the individual which was launched on September 23, 1941 Since
454 SHIP LAUNCHING
,Topof Ground WQv r j , ~ ? p o4 Ground W~
~./~/ ~ , ~

Trigger
Fourfh Lever Sa{efyPin Th[r Lever Trigger Frame

Scole
0 6 tZ
~nches
_FIG..14.--110-TON LAUNCHINGTRIGGI~R--SETPOSITION Scale
0 6 Iz
Inches
FIG. 15.--110-TON LAUNCHINC TRIOGER--RELEASED
,that date the same triggers have been used with
POSITION
*complete success for numerous launchings, using
~)ne, two or three trigger pairs, the number de-
pending upon the size and launching weight of t h a t the first pair of triggers was in the test frame
each hull. In addition, two pairs were made with- before a decision had been made on the arrange-
out change from the same plans for successive m e n t of the releasing device. T h e test was com-
launchings of two ship classes at other shipyards. pleted b y hauling the last levers clear of their
T h e a d v a n t a g e of the mechanical trigger for a safety pins, using a simple rope bridle and block
succession of launehings recommended the de- and fall. T h e pins were then removed and the
velopment of a type for holding smaller ~¢essels on release effected b y letting go the tackle. The test
the order of destroyers and LSTs. Whereas the load was established at 80 tons per trigger or
larger triggers were somewhat complex in t h a t double the m a x i m u m designed working load.
their levers were forgings, the shafts were carefully The releasing mechanism was arranged as a
m o u n t e d in bronze bushings fitted for pressure through-shaft athwartships between the ways (2-
grease lubrication and the releasing mechanisms inch standard pipe). This was held in simple clips
were actuated electrically, the intent of the new "bushed" with 2 ~ - i n c h pipe. A hook was welded
specification was simplicity. One pair of trig- in line with each trigger and each was fitted with a
gers was to be used per hull and released manually. "keeper and stripper" for the eye of a turnbuckle
At the time, the procurement of forgings was out leading through a wire rope connection to the last
of the question and elements of structural steel lever. One hook was welded to the pipe shaft,
were suggested. H e a d r o o m was at a 15remium, alined with turnbuckle and stripper on t h a t side
however. T h e requiremerLt was t h a t 80 tons per and held while the second hook was located simi-
pair be held in a total working headroom of 2 feet larly on the other side and welded in place, to as-
for the dropping of levers, yet the gravity release sure simultaneous release. A hand lever was
feature of the first design was to be retained. This welded to an extension of the shaft, b y which the
was accomplished as outlined in Figs. 12 and 13. latter could be rotated for stripping the turn-
T h e main lever was cut from 1-inch plate, three buckles off of the hooks, thus releasing the trig-
sections of which were welded together for a total gers. T h e hand lever was fitted with a final safety
thickness of about 3 inches. T h e second lever pin preventing its motion until desired.
was made a channel-shaped weldment to cradle These trigger levers were not bushed on their
the first. T h e third and fourth levers were hung pins nor has the need of bushings been indicated
from the first and second, as illustrated. All in literally hundreds of launehings using this
elements were cut from plate with the acetylene trigger type. No strain gages were considered
torch and rough ground as required. While this necessary for the triggers in single pairs per
system has the appearance of being held up b y its launch. In preparation for launching, each trig-
bootstraps, it provides a great mechanical ad- ger man maintains sufficient tension on the turn-
vantage. The smaller levers swing clear with the buckle to keep the fourth lever clear of the trigger
larger and thus headroom is conserved as no safety pin. This has been done generally b y
clearances are necessary to prevent interference of hand, no wrench being required. Upon signal he
the larger levers with the smaller lever pins. removes the safety pin and the two pins are
This development was so urgent at the time brought to the official in charge at the launching
SHIP LAUNCHING 455

log desk. The sponsor is warned and the person ing to push the cradle up the ways after such
who is to release the hull is sent to the releasing loading impacts. This has been demonstrated in
station. This m a y be an honorary function, in fact in a n u m b e r of launchings. The a m o u n t of
which case he (or she) is accompanied by an at- overloading is not sufficient to warrant an addi-
tendant who is versed in the art and can lend his tion to the theoretical down-ways component
practical and moral support. In a special event considering the safety margins built into these
of this kind the final safety pin is polished and triggers.
engraved as a souvenir of the occasion. This is The nominal factor of safety used in the de-
pulled and the hand lever is thrown to release the signs was predicated on stresses not exceeding 30
triggers and the hull. On the average, about 10 per cent of material yield strengths based on
pounds effort is required on the hand lever which the down-ways load without reduction for grease
is about 30 inches long. This force is more de- friction. Ordinary materials were used as there
pendent upon the alinement of the pipe shaft than was no strong point in favor of weight saving and
upon the load applied to the releasing hooks, it was believed t h a t materials having good duc-
which is very moderate. tility were safer for this application than more
The third design was inspired b y the success of brittle materials of higher strength. I t is believed
the second and b y the needs of successvie launch- also t h a t the provision of h e a v y wooden buffers
ings for the Victory ship program. The arrange- and their fitting to the outline of the levers in
m e n t of levers is illustrated in Figs. 14 and 15. the released position are important details in pre-
Here one pair of triggers was used per ship and the venting the overstressing of the levers and their
last lever was carried aft in the same direction as pins when the levers are dropped.
the third lever to permit the use of simple yokes Actually, the triggers m a y be massive and yet
on the release shaft, which was turned b y a hand remain within scale to the eye, for they are
lever to effect release. This trigger was designed dwarfed b y the size of cradle and hull. Their
for 110 long tons load (220 tons per pair). The m a x i m u m size can best be established b y the head-
procurement of forgings was also a problem at the room available from the line of the ground ways
time of this design and the proportions of the to the ground or trigger pit. The digging of pits
main and second levers were considered to be too is not always practicable; for example, a pair of
large for their easy fabrication from plates as triggers m a y be in a location covered b y several
weldments. Steel castings were used therefore inches of water at high tide ; also, the larger levers
for these items and they were inspected carefully m u s t not be so h e a v y t h a t they cannot be "set"
and proved under test at twice the designed work- using simple tackle.
ing load. In addition, electrical strain gages of The levers are carried in frames assembled as
the wire grid type (Baldwin-Southwark SR-4 weldments from h e a v y plates and bolted to the
gages) were applied to the main levers as a check ground ways. Cross members in the larger
on stress and as an indication of load on the trig- trigger frames (170-ton and l l0-ton sizes) provide
gers when holding during launching preparations. large areas to which the ground-way timbers are
The construction details were kept as simple as fitted for assuming loads in compression. The
possible and the levers were not bushed on their larger triggers work through apertures in the
pins. Outside of more complex but convenient ground ways and bear on frames which are bolted
electrical signaling arrangements, the procedure to the sliding ways. The latter assure adequate
for releasing these triggers is quite similar to load distribution to the sliding-way members.
that used for the 40-ton triggers. The 40-ton trigger frames are bolted in recesses
In conclusion and in general review of the fore- in the outboard sides of the ground ways. The
going, some notes in detail m a y be of interest. sliding-way frames or pressure members for these
The basis for determining design lo~ds was sub- triggers are simple channels bolted to the sides of
ject to some discussion. Previously an allowance the cradle. Adequate bolting is provided in their
for friction usually had been made as aiding the length and no cross members are required.
holding device. The use of the full down-ways In general, the mechanical triggers a p p e a r to
gravitational component was now advocated by us assure more promptness in the starting of the
on the premise t h a t the triggers would be subjected launch than when other methods of holding are
to a certain a m o u n t of dynamic loading as blocks, used. While the time interval is short, a release
shores and cribbing were removed from beneath effected b y sawing logs, burning sole plates or
the hull and, further, t h a t because of trigger resil- using sluggish hydraulic triggers usually is ac-
ience the apparent static load on triggers might companied b y a certain amount of creeping or
exceed the down-ways component because of dragging as the final resistance of the holding de-
frictional resistance to trigger deflections a t t e m p t - vice is overcome. In comparison, the mechanical
456 SHIP LAUNCHING

trigger permits the full down-ways component of the burrs are chipped off and the surfaces are built
gravitational force to be applied almost instanta- up b y welding, laying on and grinding flush a
neously to the acceleration of the hull and cradle layer of harder metal, which is an i m p r o v e m e n t
mass and to the overcoming of "starting friction." as well as a repair.
While the load applied to the triggers is eccen- After the triggers are set up in the ground ways
tric with respect to the ground ways, the resulting they are checked b y an experienced mechanic who
couple is readily handled by the distribution of the assembles the releasing mechanisms and makes
forces through the bolting of the trigger frame and any necessary adjustments. T h e externals are
by the weight of the hull and cradle which prevent • painted red and green for port and starboard sets
the tilting of the whole assembly. The principal and otherwise kept bright and clean.
load is applied to the ground ways in compression. Due to the small headroom available, the turn-
This is appreciated especially when a launching buckle and wire rope combination was selected as
must be held up for any reason, when most or all a simple and flexible holding arrangement for the
• of the hull weight is on the cradle. For example, fourth lever in the 40-ton trigger systems. These
in a t a n d e m launching a floating barrier was cast do not lend themselves to protection b y means of
adrift b y the wave motion due to the first hull buffers however and the turnbuckle screws usually
launched and was carried across the end of the take a beating. As their loading is v e r y conserva-
slipway b y the river current. For 20 minutes of tive, they can often be straightened and if they
the time required to clear this obstruction the sec- m u s t be replaced their cost is insignificant.
ond hull was held b y the triggers alone. In an- Reverting to basic design features, it is pos-
other case a rivet hole in the shell plating was un- sible to improve the mechanical advantage of
covered upon removing the last bilge cribbing un- trigger lever systems b y the use of toggles or b y
der a vessel and nearly as much time was con- carrying the points of applied loads close to the
sumed in welding, grinding and painting the spot. lever pin centers throughout the train. The use of
The creeping of the hull under such circumstances, toggles implies some research to determin ~_ the
when held b y the forward end of the cradle, is effects of friction on the extent to which one m a y
nerve wracking, whereas the mechanical trigger go in taking advantage of the toggle action. Me-
inspires confidence b y relative freedom from creep chanical friction varies with the condition of the
after the loads are fully established on the triggers. trigger and the state of the weather. The simple
Observations of the triggers released b y sole- lever systems were feasible and were felt to be
noid-controlled h a m m e r s have been made b y sight- more dependable than toggles. T h e shortening
ing across individual pairs and by watching the of the "short" levers and lengthening of "long"
bank of "released" signal lamps. As nearly as the levers to apply loads close to the pin centers, in the
eye can tell, the release of all triggers is simultane- train following the main lever, requires the use of
ous. trunnions rather than through pins. Also, the ef-
As an ultimate precaution, a crew has been fects of pin and lever bearing friction in resisting
trained to trip the solenoid latches b y hand upon release are more pronounced with greater mechani-
a given signal. T h e men take p a r t in the trigger cal advantage per lever. An added lever is not a
rehearsals prior to the start of launching events serious complication. Through pins and a nomi-
and they are adept to the extent t h a t there is no nal mechanical advantage per lever were given
apparent difference in the signal lamp response preference therefore in these designs.
whether the release is effected manually or electri- In setting up the sliding ways, the sections for-
cally. ward of trigger locations are jacked aft into con-
No mechanism is perfect b u t thus far the trou- tact with the triggers and with each successive
bles with these triggers have been few and con- section in order to assure the transmittal of load
cerned chiefly with maintenance. The larger to each trigger as uniformly as possible and with
triggers are bulky and in moving t h e m to the the least amount of creeping. With a single pair
slipways or to storage they m a y suffer collisions of triggers, those sections aft of the trigger loca-
with other objects. The resulting damage has tions are jacked aft until clearance or lost motion
been minor and no complete replacement of any in their connecting links is taken up, thus ena-
part has been required. T h e lever contact sur- bling these links to transmit load in tension from
faces could not be designed to eliminate all faults the after sections to the triggers. When two or
and so were left perfectly flat. In release they more pairs of triggers are used, intermediate
are subject to rolling and sliding and the loads sliding-way sections between trigger sets are
are transferred to a small area at the ends of the jacked aft into contact and additional clearance is
long levers with the result t h a t these ends be- provided in their connecting links immediately aft
come turned over and burred. After some use, of the forward triggers. To summarize, all sec-
SHIP LAUNCHING 457

tions forward and intermediate are loaded in com- interest in reflecting British practice and it is
pression with no load on the connecting links. thorough in scope on the design of a mechanical
The links of sections aft of the aftermost trigger trigger quite similar in arrangement to the 170-ton
pair are stressed in tension. The actual loads on solenoid-operated trigger previously described.
the triggers are predicated partly on this method of
handling the sections and partly on the general ACKNOWLEDGMENT
distribution of hull weight on the cradle. As a
rule, the after triggers assume more of the total As is usual in any development which takes
load down the ways than do the forward sets. place over a number of years, the thoughts and
At the time of these trigger developments there ideas of m a n y people form a background for the
was practically no comprehensive literature on t h e subject and successful practice generally will be
subject. Recently a paper on "Launching Trig- found to embody much of what has been proved
gers" was presented before the N o r t h - E a s t Coast previously. In this paper acknowledgment is
Institution of Engineers and Shipbuilders, b y lXlr. made to the m a n y sources from which basic in-
H. B. Robin Rowell, a Vice-President of t h a t In- formation has been drawn, and particularly to
stitution. The date on the advance copy of this Professor Keith's chapter on "La'anehing" in the
paper was 26 J a n u a r y 1945 and it was published in textbook on "Principles of N a v a l Architecture,"
the Transactions of the N o r t h - E a s t Coast Institu- published b y the Society and also to the paper b y
tion :;f Engineers and Shipbuilders, Volume 61, Mr. J. 2yr. YleNeill on the "Launch of the Quad-
1944-1945. I t was also published in two issues of ruple-Screw Turbine Steamer Queen Mary," pub-
the magazine Shipbuilding and Shipping Record, lished in the Transactions of the Institution of
dated February 1,5 and March 1, 1945. I t is of Naval Architects for 193,5.

S-ar putea să vă placă și