Documente Academic
Documente Profesional
Documente Cultură
[PDF]
White paper:Increased Design Strength for Masonry in the 2013 Code
www.floridamasonry.com/assets/resources/whitepaperjanuary2015.pdf
Code Requirements and Specification for Masonry Structures (TMS 402/602-13, ACI. 530/530.1-13,
ASCE 5/6-13). The Building Code Requirements and Specification for Masonry Structures contains two
standards and their commentaries: Building Code Requirements for Masonry Structures (TMS 402, ACI
530, ASCE 5) ...
[PDF]
to Optimize Structural Masonry - Structural Engineers Association of ...
www.seaopa.org/.../20150604%20Tips%20for%20Optimizing%20Structural%20Mas...
Jun 4, 2015 - TMS 402-11 /ACI 530-11 /ASCE 5-11. TMS 402-13 /ACI 530-13 /ASCE 5-13. Building
Code Requirements for Masonry Structures. TMS 602-11 /ACI 530.1-11/ASCE 6-11. TMS 602-13 /ACI
530.1-13/ASCE 6-13. Specification for Masonry Structures. Commentary for each. Non-mandatory. Get
started right…
[PDF]
Structural Masonry Special Inspection - Masonry Institute of Hawaii
www.masonryhawaii.com/download/.../structural_masonry_special_inspection.pdf
May 25, 2016 - In this presentation the Masonry Standards Joint Committee's. (MSJC) Building Code
Requirements for Masonry Structures. (TMS 402/ACI 530/ASCE 5) is hereafter referred to as the. MSJC
Code, and the MSJC's Specification for Masonry. Structures (TMS 602/ACI 530.1/ASCE 6) is hereafter
referred.
[PDF]
Design Guidelines for Masonry Structures: Out of Plane ... - Quakewr…
www.quakewrap.com/.../DesignGuidelinesforMasonryStructuresOutofPlaneLoads.pdf
by N Galati - Cited by 12 - Related articles
Committee 440, Fiber Reinforced Polymer Reinforcement, and is the Chair of ACI. Committee 437,
Strength Evaluation of Existing Concrete Structures. RESEARCH SIGNIFICANCE. A design
methodology for the FRP strengthening of un-reinforced masonry walls subject to out of plane loads is
presented. Non-Bearing and ...
[PDF]
MASONRY SYSTEMS
www.h-b.com/digitalcatalog/files/assets/common/downloads/page0009.pdf
530-13/ASCE 5-13 indicates maximum offset of 1-1/4" for standard 3/16" diameter pintle.) Also ideal for
wide cavity conditions, where a standard 3/16" pintle would not satisfy lateral load requirements. (Note:
TMS 402-13/ACI 530-13/ASCE 5-13 indicates maximum allowable span of 4-1/2" for standard. 3/16"
diameter pintles ...
https://www.google.com.ph/search?q=aci+530-13+pdf&dcr=0&ei=4iihWqbyG4e10ASz_4zgBg&start=20&sa=N&biw=1280&bih=620 1/2