Documente Academic
Documente Profesional
Documente Cultură
3M Fluorosurfactant
™
FC-4430
Introduction Typical Physical Properties
3M™ Fluorosurfactant FC-4430 is a non-ionic polymeric (Not for specification purposes)
fluorochemical surfactant belonging to a class of coating
additives which provide low surface tensions in coating Properties Typical Values
systems best served by fluorochemical surfactants. Appearance Clear, yellow viscous liquid
3M fluorosurfactant FC-4430 contributes excellent Specific gravity 1.14 g/cc
wetting, spreading and leveling properties to a variety Flash point (Setaflash closed cup) >93ºC (200ºF)
of coating systems. pH (of 1% aqueous solution) 4.5
Viscosity (cP @ 25°C / 77°F) 2,000 - 6,000
Suggested Applications Solubility in water Dispersible in all proportions
3M fluorosurfactant FC-4430 may be used as a flow Tg < 0°C
and leveling agent in various applications including Type Non-ionic
architectural coatings, inks, paints, adhesives, caulks, 90% polymeric fluorochemical actives
high solids coatings, water reducible coatings, radiation Composition 8% non-fluorochemical actives
curable coatings and other industrial coatings. 2% co-solvent (NMP, toluene)
Freeze/thaw stability Protect from freezing*
3M fluorosurfactant FC-4430 can be used in both water
and solvent based coating formulations and can provide * If 3M fluorosurfactant FC-4430 freezes, warm it to >86°F (>30°C) until fluid.
Freezing will not change physical properties or adversely affect performance.
benefits for dirt pick up resistance and stain resistance in
certain applications.
Recommended use level is between 0.05% and 0.3% Surface Tension/CMC (in water)
active surfactant. However, use level can vary depending 3M fluorosurfactant FC-4430 is very efficient at reducing the
on the application and concentration of other additives surface tension in aqueous coating systems.
and solvents in the formulation.
80
70
60
Surface Tension (mN/m)
50
40
30
20
10
0
Note: All values determined at 77°F (25°C) 0 500 1000 1500 2000 2500 3000 3500 4000 4500 5000
unless otherwise specified Concentration (ppm)
Foaming Solubility
3M Fluorosurfactant FC-4430 shows low tendency
™
Solvent Solvent grams of FC-4430/100 grams of solvent
to form foam in aqueous systems. This can translate
into the ability to use less defoamer and/or a less Butyl cellusolve >25
Packaging
3M fluorosurfactant FC-4430 is currently available in:
• 8 lb. pails
• 40 lb. drums
• 250 lb. drums