Documente Academic
Documente Profesional
Documente Cultură
3- What is the maximum weight that can be used from the BHA for
WOB? Why?
…………………………………………
…………………………………………
6- What is the maximum allowable over pull while POOH in vertical and
horizontal well
…………………………………………
a- True b- false
…………………………………………
10- What is the idea behind drill line slip & cut program? List all steps
for making slip and cut?
………………………………………
…………………………………………
…………………………………………
…………………………………………
12- Why should the well be closed in quickly after a kick has been
detected?
Choose three
a.Minimize the influx into the well bore
b.Minimize the SICP
d.Minimize the bottom hole press.
e.Minimize the casing shoe pressure.
a.Start circulation with pre calculated rate and kill the well with barite.
b.Shut the blowout preventer
c.Pull to the shoe quickly.
d.Call the tool pusher and company man.
e.Close the well in properly
14-If the formation pressure gradient increases from 0.60 psi/ft at 12000
ft to 0.62 psi/ft at 12700 ft, and the mud weight is 12 ppg through the
interval, the
19- Pump stroke counter is the accurate to measure the mud to keep the
hole full when P.O.O.H.
a )true b )false
20- On mud pump, oil level for both gear box and chains should be
checked
a- Weekly b- Daily c- Each Tour
a- Decreased b- Increased
a- False b- True
23- The sand trap compartment below the shale shaker is a very
important part of the mud /solids separation.
a- False b- True
24- Which of the following should increase by increasing bit weight?
26- What are the causes of shale to sloughs into the hole?
28- The driller’s decision to pull a worn drill bit should be based on:
29- If the mud checked with V-G meter and the following numbers
recorded, at 600 RPM is 85 & at 300 RPM is 50 .What would the yield
value be ?
a- 25 LB.F/100 FT2
b- 35 LB.F/100 FT2
c- 5 LB.F/100 FT2
d- 15 LB.F/100 FT2
a- False b- True
35- If the viscosity is low and if the drilling assembly is not balled up
there is no negative pressure loss.
a- False b- True
36- Vacuum pump on the degasser compresses gas inside the vacuum
tank.
a- False b- True
37- When the three way valve is fully open, the vacuum in the vacuum
tank is broken and less mud pulled in.
a- False b- True
38- The main purpose of the discharge jet is to remove gas from the
mud.
a- True b- False
39- The main purpose of the baffle plate in vacuum degasser is to allow
the mud to form as a thin layer so the vacuum can pull gas out of the
mud.
a- False b- True