Documente Academic
Documente Profesional
Documente Cultură
SPECIFICATIONS
CUSTOMER PTC
:
SAMPLE CODE (Ver.)
:
MASS PRODUCTION CODE (Ver.) PC1602LRS-FWB-B-Q (Ver.0)
:
PC-95003
DRAWING NO. (Ver.)
Customer Approved
Date:
Please contact Powertip or it’s representative before designing your product based on this specification.
NO.PT-A-005-6
RECORDS OF REVISION
Date Rev. Description Note Page
Total:21 Page
2. MODULE STRUCTURE
2.1 Counter Drawing
2.2 Interface Pin Description
2.3 Timing Characteristics
2.4 Display Command
2.5 Character Pattern
3. QUALITY ASSURANCE SYSTEM
3.1 Quality Assurance Flow Chart
3.2 Inspection Specification
4. RELIABILITY TEST
4.1 Reliability Test Condition
5. PRECAUTION RELATING PRODUCT HANDLING
5.1 Safety
5.2 Handling
5.3 Storage
5.4 Terms of Warranty
6. THIS PRODUCT CONFORMS THE ROHS OF PTC.
Note:For detailed information please refer to IC data sheet:ST7066U,KS0065B
Interface -
Other -
∅
Z’
θ1 θ2
Light (when transmitted ) Y(∅=0°)
viewing angle θ (∅ fixed)
(θ=90°)
Note : Optimum viewing angle with the
naked eye and viewing angle θ at
Cmax. Above are not always the same
Brightness (reflection) of
selected dot
0
(%) -VLCD
Brightness
Non-selected state Selected state Non-selected state
B2 (reflection) of
Contrast
unselected dot 90%
Brightness
B1
10%
(reflection)
Time
tr tf
Maximum Ratings
Item Symbol Conditions Min. Max. Unit
Forward Current IF Ta =25℃ - 300 mA
Reverse Voltage VR Ta =25℃ - 8 V
Power Dissipation PO Ta =25℃ - 1.38 W
VDD
2
VO
LCD MODULE
10~20KΩ 3
VSS
1 15 16
4.2V
RS VIH1
VIL1
TAS TAH
R/W
TPW TAH
E
TR TDSW TH
DB0-DB7 Valid data
TC
●Reading data from ST7066U to MPU
RS VIH1
VIL1
TAS TAH
R/W
TR TPW TAH
E
TDDR TH
TC
Info Survey
Contract
Design check
Sample test
Sample
Approval NG
Verification
NG OK
Sample approval OK
Info Claim
Failure analysis
Analysis report
Sales
Service Corrective action
Tracking
N.G. Minor
Assembly parts
10 D’ Pad
A=( L + W )÷2
End solder joint width, D’ is >50% width of
N.G. Minor
component termination or width of pad
Side overhang, D is >25% width of component
N.G. Minor
termination.
Component is cracked, deformed, and burned, etc. N.G. Minor
The polarity of component is placed in inverse
N.G. Minor
direction.
Maximum fillet height of solder extends onto the
component body or minimum fillet height N.G. Minor
is <0.5mm.