Documente Academic
Documente Profesional
Documente Cultură
G4 CPU Upgrade
Tray-Loading iMac
! IMPORTANT!
Before doing any work on your iMac,
BACK UP ALL IMPORTANT DATA
from your hard drive! FastMac is not
responsible for any loss of data during
the upgrade process!
!
+
1 2
1. Shut down the computer. Unplug all 2. Set the computer, screen down, on a
cables, including the power cable. Wait soft, clean cloth so that the bottom of
five (5) minutes for components to the computer is facing you. Do this,
cool. preferably, in a clean, dry, well-lit area.
Remove I/O cover.
3 4
3. Loosen captive screw on access cover 4. Using the handle, quickly jerk the
inside the handle. lower access cover up and towards
you.
5 6
5. Remove the two (2) screws at the top of 6. Disconnect the screw clamp and irDA cable.
the logic board/mass storage chassis.
Put the screws in a safe place.
7 8
7. Disconnect the RGB cable. 8. Disconnect the audio and main power cables.
9 10
9. Using the handle, pull up on the chassis 10. Place Mass Storage Chassis on table as
and slide the logic board/mass storage shown.
chassis out of the unit.
IMPORTANT: To avoid electrostatic discharge, always
ground yourself by touching bare metal before you touch
any parts or install any components inside the computer.
11 12
11. Remove the top shield from the 12. Pry the heatsink clip off the processor
processor card. shield frame.
13 14
13. Remove the heatsink clip. 14. Lift the heatsink off the processor card.
Caution: Heatsink may be hot.
15 16
15. Pry the processor card from the logic 16. Remove the processor card.
board connectors.
17 18
17. Pull the metal snap on either side of the 18. Pull the RAM DIMM out. If there is
RAM DIMM outward. another RAM DIMM on the backside of
the processor, repeat steps 17 & 18.
19
1 2
1. Remove upgraded Processor Card from 2. Reinsert the RAM DIMM(s). Snap into
Anti-Static bag. place. Make sure the metal snaps are
secure. Repeat on backside if installing
more than one RAM DIMM.
3 4
5 6
5. Place the heatsink on the processor card. 6. Reattach the heatsink clip. Make sure
that the heatsink is firmly held in place
by the clip.
7 8
7. Reattach the top shield to the shield 8. Holding by the handle, slide the logic
frame. board/mass storage chassis back into the
unit.
9 10
9. Reconnect the main power cable. 10. Reconnect the audio cable.
11 12
11. Reconnect the RGB cable. 12. Reconnect the screw clamp and irDA
cable..
13 14
13. Replace the two (2) screws at the top of 14. Reattach the lower access cover by
the logic board/mass storage chassis. sliding it back into place. Press on the
cover to secure it.
15 16
15. Tighten captive screw on access cover 16. Reattach I/O cover.
inside the handle.
17 18
17. Place your iMac in the upright position. 18. Reconnect all the cables to your iMac,
including power
19
OS X Users
If you are running OS X, we recommend
reinstalling your OS.
Purchaser’s sole remedy under this warranty shall be, at FastMac’s sole discretion, refund, repair or replacement as provided in this
warranty. FastMac’s warranty shall not apply to any failure or defect caused by misuse, abnormal use, neglect, abuse, alteration,
improper installation, unauthorized repair or modification, improper testing, accident or causes external to the product such as
but not limited to excessive heat or humidity, power failure, or surges, or improper installation, or damage arising from improper
packaging during transport; and damage resulting from causes, including without limitation, lack of technical skill, competence, or
experience of the user.
FASTMAC IS NOT RESPONSIBLE FOR DIRECT, SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM ANY BREACH
OF WARRANTY OR CONDITION, OR UNDER ANY OTHER LEGAL THEORY, INCLUDING BUT NOT LIMITED TO LOST PROFITS, DOWNTIME,
GOODWILL, DAMAGE TO OR REPLACEMENT OF EQUIPMENT AND PROPERTY, ANY COSTS OF RECOVERING, REPROGRAMMING, OR
REPRODUCING ANY PROGRAM OR DATA STORED IN OR USED WITH FASTMAC PRODUCTS, AND ANY FAILURE TO MAINTAIN THE CON-
FIDENTIALITY OF DATA STORED ON THE PRODUCT. FASTMAC SPECIFICALLY DOES NOT REPRESENT THAT IT WILL BE ABLE TO REPAIR
ANY PRODUCT UNDER THIS WARRANTY OR MAKE A PRODUCT EXCHANGE WITHOUT RISK TO OR LOSS OF PROGRAMS OR DATA. Some
states do not allow the exclusion or limitation of incidental or consequential damages or exclusions or limitations on the duration of
implied warranties or conditions, so the above limitations or exclusions may not apply to you. This warranty gives you specific legal
rights, and you may also have other rights that vary by state.
Use of software and /or configurations are at your own risk and are not considered covered under any warranty. FastMac and its
associates are not liable for damages resulting from the use of the instructions or software provided.
Non-defective purchases which are returned to FastMac must be returned within thirty (30) days of purchase. For non-defective
purchases which are returned or refused by the Purchaser, FastMac will, at its discretion, issue a credit or refund for the purchase
price of the goods, less all shipping charges incurred in the shipment and a restocking fee of no less than fifteen percent (15%) of
the price of the goods.
Warranty Information • 13