Documente Academic
Documente Profesional
Documente Cultură
(behind the stroller). Example: The swivel lockout knob is on the left reclining straps until you obtain surfaces together (Fig. 24). LIMITED WARRANTY
side of the stroller. the desired position. The seat Shoulder
back can be adjusted to recline Strap 14 TIRE PRESSURE: IMPORTANT: BOB Trailers Inc. takes pride in its workmanship and strives to
Fine tune tracking of stroller is accomplished by using the tracking anywhere between the fully Inflation pressure must always fall manufacture the best products possible. Therefore, we warranty our
adjustment knob shown in Fig. 13. If your stroller pulls to the left, turn upright position and the fully within the range embossed on the sidewall Revolution Strollers against defects in material and workmanship
the knob counter-clockwise 1/2 turn. If your stroller pulls to the right, reclined position (Fig. 19 & 20). of the tire (usually 25-35 p.s.i.) subject to the conditions listed below. Since no product is indestructible,
turn the knob clockwise 1/2 turn. Repeat Roll test and adjustment it does not cover defects attributable to or resulting from normal wear,
Frame
until the stroller rolls straight. 12 SHOCK ABSORBERS: The STROLLER CARE & Release abuse or alteration.
suspension system features MAINTENANCE: The fabric is 100% Handle
two shock positions to provide a polyester with a stain resistant Frame is warranted for 5 years.
Locking
88 PARKING BRAKE: Pin comfortable ride for kids of treatment that makes cleanup easy. Components and fabric are warranted for one year.
The brake is a different weights. The two Use a sponge with a solution of mild Fig. 22 Warranty is only valid for the original purchaser.
parking brake, it positions are shown in Fig. 2. Fig. 17 Securely adjust shoulder straps. soap and lukewarm water (maximum Proof of purchase is required to exercise this warranty.
prevents the stroller Position 1 is intended for temperature of 100 degree Fahrenheit). Pull handle upwards Labor and freight charges are not included.
occupants up to 40 lbs. (18 kg), sharply to fold.
from moving while Rinse thoroughly with clean water to remove Normal wear, neglect, abuse, accidents, improper assembly or
loading and unloading while position 2 is intended for Sternum soap then air dry. Do not use detergent. maintenance, or the installation of parts or accessories not compatible
occupants from 40 to 70 lbs. (18 Strap Regular maintenance should include: Verifying tire pressure, verifying
it. The parking brake with the original intended use of the stroller, as sold, are not covered
is not designed as a Brake Bar Locking to 32 kg) total. The stroller that all screws and fasteners are tight, and wiping parts clean with by this Warranty.
stopping brake. Do (Locked Position) Disk features a metal shock bracket a rag. To reduce the possibility of squeaks, periodically Warranty claims must be made through an authorized dealer.
not use the brake to with a sliding track and spring apply a small amount of lubricant (Triflow, 3-in- This warranty is limited to the repair or replacement of the defective
one, or light sewing machine oil) to the frame
slow or stop the Fig. 14 Parking Brake - Locked position. loaded shock pin that
pivot axle and interior faces of the pivot part. BOB shall in no event be responsible for consequential or
stroller. The brake is automatically locks in place when bracket, as shown in Fig. 25. special damages.
intended to park the it aligns with either of the two This Limited Warranty is the only express or implied warranty
stroller on flat shock positions. Shock position STORAGE: It is best to store applicable to BOB. Any implied warranties, including warranties
surfaces, not on Locking adjustments should be made with your stroller indoors when of merchantability and fitness shall be limited in scope and duration
inclines. Never leave Pin the stroller unloaded. The shocks Fig. 18 Connect sternum strap. in accordance with this limited warranty.
it is not in use. This will
your children in the will lock into position 1 when prolong its attractive
stroller unattended unfolding the stroller. To use the appearance. Extended STROLLER ACCESSORIES
with or without the stiffer shock position, move the Seat Reclining exposure to the sun's Fig. 23
parking brake set! shock from position 1 to position Ladder Locks
ultraviolet rays can fade and Stroller in fully folded position.
2 by depressing the shock release damage the fabric, tires, and
To set the parking Locking button (Fig. 2) with one hand, and plastic parts.
brake, press the brake Brake Bar Disk with the other hand, lift slightly
bar down into the (Unlocked Position) and pull the shock backward. CARGO: The stroller is equipped with two small seat pockets for
locked position (Fig. When the shock pin is properly your child, a seatback
Fig. 15 Parking Brake - Unlocked position. aligned in position 2, the pin will
14) with your foot pocket and a Low Boy
making sure the snap into place. Repeat this cargo pouch under the Handlebar
locking pin fully engages the locking disk. To ensure the brake is set process for the second shock. To Fig. 19
stroller. Adding weight
properly, attempt to roll the stroller fore and aft after setting the brake. move the shock from position 2 to the seatback
If the stroller will not roll, the brake is set properly. To release the to position 1, reverse the above changes the center of
process for both shocks. Reclining
parking brake, lift up on the brake bar with your foot until it springs Strap gravity of the stroller,
up into the fully unlocked position (Fig. 15). and increases the
13 FOLDING: Remove children
possibility that it will tip
99 SUN CANOPY: The stroller features a two position canopy. To fully from stroller. Remove the over backwards. For
open the canopy, rotate the assembly forward until the fabric is taut. contents of the Low Boy cargo this reason, loads in the
pouch. The shock absorbers Warm Fuzzy Seat Insert -
The rear canopy flap should be freed from the Velcro to give additional seatback pocket should
must be in position 1 (Fig. 2) The ultimate in plushness
sun protection. To reduce the size of the sun canopy, pull the canopy never exceed two
before folding. Press both the & comfort. Thick,
toward the handlebar. The additional fabric can be gathered by pulling pounds (1 kg.). Cross Your little one will be
right and left handlebar release Tube polypropylene fleece
the canopy drawstring (Fig. 1) and securing the cord lock. Fig. 20 Seat in fully reclined position. Although the seatback dry & comfortable in bad
levers (Fig. 3), and fold the will give you and
is padded, it is important Wrist weather, strolling with the
handlebar forward as shown in Velcro your child a warm fuzzy!
10 SEAT SAFETY Shoulder to remember that this is Strap BOB Weather Shield!
HARNESS: Set parking Strap Fig. 21. Locate the frame release handle underneath the seat (Fig. what your child leans Fig. 24 Secure stroller in folded position.
brake before placing child in 22) and pull upwards sharply. This will allow the lower frame to fold against. Never place
stroller. To secure your child Buckle together, as shown in Fig. 23. sharp or injurious
in the seat, put one strap (grey The folded stroller can be made objects into the seatback pocket.
or black) over each shoulder even more compact by
and snap the male buckle into removing the front and rear
wheels. The front wheel is Apply Lubricant
the female receiver on the to Interior Faces
crotch strap (Fig. 16). Adjust removed by opening the front of Bracket
shoulder straps to be snug and wheel quick release and
secure (Fig. 17). Connect and removing the wheel (see
adjust the sternum strap (red), section 5). The rear
see Fig. 18. wheels are removed by
WARNING: Never place Fig. 16 Place straps over shoulders releasing the parking
passengers in the stroller and secure to buckle. brake (See section 8), At your finger tips storage
without securing them in the and then opening the rear Fig. 21 for two watterbottles or infanT
harness. Unrestrained passengers can affect the control of the stroller. wheel quick release (Fig. 4), Stroller with handlebar folded. drinks and other small car seat
and removing the wheels.
Passenger Weight Limit - 70 Pounds (32 Kilograms)
The Wrist Safety Strap can be used
Apply Lubricant
to Axle
items. 4 Velcro straps for adapter
easy attachment.
11 RECLINING SEAT: Set parking brake before making any seat to keep the stroller in the folded position for transport and Allows quick attachment of
adjustments. To recline the seat, rotate the ladder locks (Fig. 19) storage. With the stroller folded, loop the end of the wrist safety strap Fig. 25 leading brand car seats to your
forward thus releasing the reclining straps. To raise the seat, pull the around the handlebar and back to the cross tube and fix the Velcro stoller. Folds with stroller.
Pivot Axle Lubrication