Sunteți pe pagina 1din 11

文档名称 文档密级

The analysis of the retainability on sites(JKB680- TOLGATECKR6SECMW and JKP052-


RKPECENONGAN6SECMW) as following.
The formula:

The PS CCSR and HSDPA CCSR and the CS CCSR all are ok(98%) for the whole NodeB- JKB680.

The PS CCSR and HSDPA CCSR, CS CCSR are ok for all cells in this site.

2018-5-15 华为保密信息,未经授权禁止扩散 第 1 页, 共 11 页
文档名称 文档密级

From PCHR log, there is 213 times PS calldrop, the CCH(PCH+FACH) call drop is up to 152
times(71%), so the DCH&H call drop is only 61(29%).

The HSDPA CCSR and the CS CCSR all are ok(98%) for the whole NodeB- JKP052. The PS CCSR
is lowly.

2018-5-15 华为保密信息,未经授权禁止扩散 第 2 页, 共 11 页
文档名称 文档密级

The CS CCSR is ok for all cells in this NODEB- JKP052

The HSDPA CCSR is fluctuation for some cells in this NODEB- JKP052,such as
20525,40529,40526.etc

And the PS CCSR is lowly for all cells in this NodeB-- JKP052.

The analysis of the PS CCSR decrease, the mainly reason is


“RR_ERR_RNCAP_RB_CU_OVERLAP_BACK “ means cell update and RB RECFG procedure
overlapping.

2018-5-15 华为保密信息,未经授权禁止扩散 第 3 页, 共 11 页
文档名称 文档密级

For the reason of ” RR_ERR_RNCAP_RB_CU_OVERLAP_BACK”,RNC doesn’t recived the RB


RECFG CMP with the downlink RL Unsynchronize, When the RB RECFG CMP TIMEOUT
Casued the IU release , at same time,UE sends the CELL_UPDATE with RL fail
reason.Because the RL reset of RB RECFG timeout isn’t enabled in current version (R14
SPC535:SET UCORRMPARA: ReservedSwitch1=RESERVED_SWITCH_1_BIT20-1;) , so the cell
update and RB RECFG procedure overlapping casued the PS call drop.

2018-5-15 华为保密信息,未经授权禁止扩散 第 4 页, 共 11 页
文档名称 文档密级

Trouble Ticket DTS2012122002846


Number

Description In the physical channel reconfiguration or RB reconfiguration


procedure, poor quality of radio signals causes UEs to be dropped
from the network.

Severity Suggestion

Root Cause In the physical channel reconfiguration or RB reconfiguration


procedure, when the quality of radio signals is poor and the timer
for the RNC to wait for a PHYSICAL CHANNEL
RECONFIGURATION COMPLETE or RADIO BEARER
RECONFIGURATION COMPLETE message from the UE expires
or the RNC receives a cell update message with the cause value
of "radio link failure" or "RLC Unrecoverable error", the RNC will
abnormally release services.

Solution The following scenarios of triggering radio link reestablishment


have been added to the RNC:
Scenario 1: In the physical channel reconfiguration procedure, the
timer for the RNC to wait for a PHYSICAL CHANNEL
RECONFIGURATION COMPLETE message from the UE expires,
or the RNC receives a cell update message with the cause value
of "radio link failure" or "RLC Unrecoverable error".Scenario 2: In
the RB reconfiguration procedure, the timer for the RNC to wait for
a RADIO BEARER RECONFIGURATION COMPLETE message
from the UE expires, or the RNC receives a cell update message
with the cause value of "radio link failure" or "RLC Unrecoverable
error".
In scenario 1,
RESERVED_SWITCH_1_BIT19 of the ReservedSwitch1
parameter in the SET UCORRMPARA command is now used to
control whether the RNC triggers radio link reestablishment.
By default, this switch is turned off (with the bit set to 0).
When this switch is turned on, the RNC triggers radio link
reestablishment.
When this switch is turned off, the RNC does not trigger radio link
reestablishment.
Run the following MML command to turn on this switch:
SET UCORRMPARA:
ReservedSwitch1= RESERVED_SWITCH_1_BIT19-1;
Run the following MML command to turn off this switch:
SET UCORRMPARA:
ReservedSwitch1= RESERVED_SWITCH_1_BIT19-0;

In scenario 2,
RESERVED_SWITCH_1_BIT20 of the ReservedSwitch1
parameter in the SET UCORRMPARA command is now used to
control whether the RNC triggers radio link reestablishment.

2018-5-15 华为保密信息,未经授权禁止扩散 第 5 页, 共 11 页
文档名称 文档密级

By default, this switch is turned off (with the bit set to 0).
When this switch is turned on, the RNC triggers radio link
reestablishment.
When this switch is turned off, the RNC does not trigger radio link
reestablishment.
Run the following MML command to turn on this switch:
SET UCORRMPARA:
ReservedSwitch1= RESERVED_SWITCH_1_BIT20-1;
Run the following MML command to turn off this switch:
SET UCORRMPARA:
ReservedSwitch1= RESERVED_SWITCH_1_BIT20-0;

In the preceding two scenarios, the function of radio link reestablishment must have
been enabled.
 RESERVED_SWITCH_1_BIT19 must be used together with
RNCAP_PHY_RECFG_REEST_SWITCH.
RNCAP_PHY_RECFG_REEST_SWITCH is specified by the
PROCESSSWITCH4 parameter in the SET URRCTRLSWITCH command.
 RESERVED_SWITCH_1_BIT20 must be used together with
RESERVED_SWITCH_1_BIT14. RESERVED_SWITCH_1_BIT14 is specified
by the ReservedSwitch1 parameter in the SET UCORRMPARA command.
Scenario 1 supports only the following three procedures:
 Serving cell change
 Code tree reshuffling
 Intra-frequency or inter-frequency hard handover (the RNC triggers link
reestablishment only when the timer for the RNC to wait for the PHYSICAL
CHANNEL RECONFIGURATION COMPLETE message expires)

Solution Impact In the preceding scenario, this solution decreases the PS call drop
rate and the CS call drop rate.
Test Case ID CASE_Commercial_PR_Regression_V9R14C00SPC535_005
For the reason of ” RR_ERR_RNCAP_CU_WAIT_UE_RSP_TIMEOUT”, which is caused by bad
coverage.

For the reason of ” RR_ERR_RNCAP_FHHO_TIMER_EXPIRE_DCH” means RL RESET FAILURE,


2018-5-15 华为保密信息,未经授权禁止扩散 第 6 页, 共 11 页
文档名称 文档密级

which is also caused by bad coverage.

The analysis of the HSDPA CCSR decrease, the mainly reason is


“ RR_ERR_RNCAP_FHHO_TIMER_EXPIRE_DCH” means RL RESET FAILURE(Radio link reset
failure).

For the “ RR_ERR_RNCAP_FHHO_TIMER_EXPIRE_DCH” means RL RESET FAILURE, RNC


doesn’t receive the CELL_UPDATE message from UE till the timer(SET UCACALGOSWITCH:
RsvdPara3=35000;) expiry
2018-5-15 华为保密信息,未经授权禁止扩散 第 7 页, 共 11 页
文档名称 文档密级

For the “ CRA_CELL_RR168658958” means reasources’ congestion.here is FACH users’


congestion

From the signalling , UE reselect to the FACH congested CELL 49239 after H2F. Which casued the
H2F failure, and then HSDPA abnormal release lead to the HSDPA calldrop.

2018-5-15 华为保密信息,未经授权禁止扩散 第 8 页, 共 11 页
文档名称 文档密级

For the reason of ” SHO_WAIT_ASU_CMP_TIMEOUT” means RNC doesn’t receive the ASU
CMP message from UE, which is caused by bad coverage. For these timeout can’t trigger the
RL RESET, so which caused the HSDPA CALL DROP.

2018-5-15 华为保密信息,未经授权禁止扩散 第 9 页, 共 11 页
文档名称 文档密级

For the reason of ” CU_WAIT_UE_RSP_TIMEOUT” means RNC doesn’t receive the CELL
UPDATE Response message from UE after H2F with UE SRB RESET.

According to our experience, this drop scene is caused by the FMO defect of Qualcomm chips,
which we have encountered in some countries: Qualcomm chips may decode RLC PDU of other
user from other frequency cell of same sector at FMO, and then cause UE SRB RESET.
FMO (FACH Measurement Occasion) is only valid in the CELL_FACH state. UE will perform cell
reselection to inter-frequency or inter-RAT according to the FACH Measurement. FMO is stopped
when the network transitions the UE to a different state.

For the “ CRA_CELL_RR168658903” means reasources’ congestion.here is HSUPA users’


congestion

2018-5-15 华为保密信息,未经授权禁止扩散 第 10 页, 共 11 页
文档名称 文档密级

Suggestion:

RF optimization ,check the ECNO, RSCP and RTWP.

For some congestion need to solve the resources’ congestion.

For FMO rpoblem , Reduce the measurement time of inter-frequency and inter-RAT for
CELL_FACH users:
MOD UCELLMEAS: CellId=XXXX, IntraFreqMeasInd=REQUIRE,
InterFreqInterRatMeasInd=INTER_FREQ_AND_INTER_RAT,
FACHMeasInd=INTER_FREQ_AND_INTER_RAT, FACHMEASOCCACYCLELENCOEF=6;
This solution can reduce the probability of problem without obvious side-effect.

2018-5-15 华为保密信息,未经授权禁止扩散 第 11 页, 共 11 页

S-ar putea să vă placă și