Documente Academic
Documente Profesional
Documente Cultură
Other names or synonyms Novec ™ 1230 (FK 5-1-12) charged with nitrogen
1.2 Relevant identified uses of the substance or mixture and uses advised against
Emergency information service Consultank GmbH +49 (0) 178 433 7434
This number is only for transport emergencies.
As above or next toxicological information centre.
Additional information
This mixture does not contain any substances that are assessed to be a PBT or a vPvB.
EIGA-0783: Contains fluorinated greenhouse gases covered by the Kyoto protocol. .
EIGA-As: Asphyxiant in high concentrations.
Pictograms
GHS04
Hazard statements
H280 Contains gas under pressure; may explode if heated.
H412 Harmful to aquatic life with long lasting effects.
Precautionary statements
P273 Avoid release to the environment.
P410+P403 Protect from sunlight. Store in a well-ventilated place.
3.1 Substances
not relevant (mixture)
3.2 Mixtures
Index No
606-108-00-X
EC No
231-783-9
General notes
In all cases of doubt, or when symptoms persist, seek medical advice.
Following inhalation
Provide fresh air.
If breathing is irregular or stopped, immediately seek medical assistance and start first aid actions.
Mouth to mouth resuscitation should be avoided. Use alternative methods, preferably with oxygen or
compressed air driven apparatus.
Following ingestion
Rinse mouth. Do not induce vomiting.
Get medical advice/attention if you feel unwell.
4.2 Most important symptoms and effects, both acute and delayed
These information are not available.
4.3 Indication of any immediate medical attention and special treatment needed
none
Specific notes/details
None.
Flammability hazards
Protect from sunlight.
Ventilation requirements
Provision of sufficient ventilation.
Packaging compatibilities
Only packagings which are approved (e.g. acc. to ADR) may be used.
1,1,1,2,2,4,5,5,5- 756-13-8 DNEL 780 mg/m³ human, inhalatory worker (in- chronic - sys-
nonafluoro-4-(tri- dustry) temic effects
fluoromethyl)-3-
pentanone
1,1,1,2,2,4,5,5,5- 756-13-8 DNEL 1,000,000 human, inhalatory worker (in- chronic - local
nonafluoro-4-(tri- mg/m³ dustry) effects
fluoromethyl)-3-
pentanone
1,1,1,2,2,4,5,5,5- 756-13-8 DNEL 147 mg/kg human, dermal worker (in- chronic - sys-
nonafluoro-4-(tri- dustry) temic effects
fluoromethyl)-3-
pentanone
Eye/face protection
Use protective eyewear to guard against splash of liquids.
Hand protection
Respiratory protection
[In case of inadequate ventilation] wear respiratory protection.
Self-contained breathing apparatus (EN 133).
Appearance
Form pressurized
Colour colourless
Odour odourless
Explosive limits
Solubility(ies)
Partition coefficient
10.1 Reactivity
Gas under pressure.
If heated:
danger of explosion, gas under pressure, danger of bursting container
Classification procedure
The method for classification of the mixture is based on ingredients of the mixture (additivity formula).
Acute toxicity
Shall not be classified as acutely toxic.
Skin corrosion/irritation
Shall not be classified as corrosive/irritant to skin.
Carcinogenicity
Shall not be classified as carcinogenic.
Reproductive toxicity
Shall not be classified as a reproductive toxicant.
Aspiration hazard
Shall not be classified as presenting an aspiration hazard.
12.1 Toxicity
Biodegradation
The relevant substances of the mixture are readily biodegradable.
Persistence
Data are not available.
Remarks
Water hazard class - WHC (Wassergefährdungsklasse): 1 (Slightly hazardous to water)
Remarks
Please consider the relevant national or regional provisions.
Class 2.2
14.7 Transport in bulk according to Annex II of MARPOL and the IBC Code
The cargo is not intended to be carried in bulk.
UN number 1066
Class 2
Classification code 1A
Hazard identification No 20
UN number 1066
Class 2.2
Stowage category A
UN number 1066
Class 2.2
15.1 Safety, health and environmental regulations/legislation specific for the substance or
mixture
Directive 2000/60/EC establishing a framework for Community action in the field of water
policy (WFD)
none of the ingredients are listed
ADR Accord européen relatif au transport international des marchandises dangereuses par route (European
Agreement concerning the International Carriage of Dangerous Goods by Road)
CAS Chemical Abstracts Service (service that maintains the most comprehensive list of chemical substances)
CLP Regulation (EC) No 1272/2008 on classification, labelling and packaging of substances and mixtures
DGR danger
GHS "Globally Harmonized System of Classification and Labelling of Chemicals" developed by the United Na-
tions
IATA/DGR Dangerous Goods Regulations (DGR) for the air transport (IATA)
index No the Index number is the identification code given to the substance in Part 3 of Annex VI to Regulation
(EC) No 1272/2008
MARPOL International Convention for the Prevention of Pollution from Ships (abbr. of "Marine Pollutant)
RID Règlement concernant le transport International ferroviaire des marchandises Dangereuses (Regula-
tions concerning the International carriage of Dangerous goods by Rail)
Classification procedure
Physical and chemical properties.
Health hazards.
Environmental hazards.
The method for classification of the mixture is based on ingredients of the mixture (additivity formula).
List of relevant phrases (code and full text as stated in chapter 2 and 3)
Code Text
H280 contains gas under pressure; may explode if heated
Disclaimer
This information is based upon the present state of our knowledge.
This SDS has been compiled and is solely intended for this product.