Documente Academic
Documente Profesional
Documente Cultură
PARTS BREAKDOWN
FLANGE FLANGE
D2000 PARTS
REV 4/03
D2000 SWIVEL JOINT
PARTS BREAKDOWN
* Always support the outboard weight of the swivel joint with a crane or
lifting device while performing the following steps:
1. Remove the flange screws and separate the swivel joint at the split flange. Note: You can
change the seal from either side on the D2000 swivel, but it is only necessary to remove one of
the flanges.
2. Remove the seal set (it is recommended to replace the PTFE seal carrier and O-Rings).
Caution: Be careful not to scratch seal surfaces.
3. Flush seal surfaces with solvent to remove any grit that may be present. If necessary, Emory
paper (320 grit or finer) can be used to polish the surface.
5. Realign flange and initialize the threads on the screws. Once all screws have been started,
completely tighten in alternating fashion. The torque requirement is 15 ft. lbs. on screws.
Attention: D2000 swivel joints do not require field greasing for 5 years
To determine when your swivel joint will D2000 Field Greasing Kits Greasing Instructions
require greasing, please consult the date
stamp on the loading arm tag. Five years Kit includes: Each kit contains enough grease to com-
from the date of manufacture, the limited · Ball retaining screw with zirc pletely grease one swivel.
warranty on the swivel expires. You can fitting
either: · Tube of grease – consult the Remove the existing ball retaining screw
loading arm tag for the and replace with the zirc fitting screw.
1. Replace the bearing module and appropriate grease.
receive a new five year warranty. Grease the swivel taking care to rotate
the swivel as much as possible after
Or each injection.
D2000 Parts
REV 4/03