Documente Academic
Documente Profesional
Documente Cultură
Router>enable
Router#config
Configuring from terminal, memory, or network [terminal]?
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#hostname R1
R1(config)#interface FastEthernet0/1
R1(config-if)#ip address 172.17.10.1 255.255.255.0
R1(config-if)#no shutdown
R1(config-if)#
%LINK-5-CHANGED: Interface FastEthernet0/1, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/1, changed state to up
R1(config-if)#exit
R1(config)#interface FastEthernet0/1
R1(config-if)#interface FastEthernet0/1.10
R1(config-subif)#
%LINK-5-CHANGED: Interface FastEthernet0/1.10, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/1.10, changed state to up
R1(config-subif)#ip address 172.17.10.1 255.255.255.0
% Configuring IP routing on a LAN subinterface is only allowed if that
subinterface is already configured as part of an IEEE 802.10, IEEE 802.1Q,
or ISL vLAN.
R1(config-subif)#exit
R1(config)#interface FastEthernet0/1.20
R1(config-subif)#
%LINK-5-CHANGED: Interface FastEthernet0/1.20, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/1.20, changed state to up
R1(config-subif)#ip address 172.17.20.1 255.255.255.0
% Configuring IP routing on a LAN subinterface is only allowed if that
subinterface is already configured as part of an IEEE 802.10, IEEE 802.1Q,
or ISL vLAN.
R1(config-subif)#exit
R1(config)#interface FastEthernet0/1.88
R1(config-subif)#
%LINK-5-CHANGED: Interface FastEthernet0/1.88, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/1.88, changed state to up
R1(config-subif)#ip address 172.17.88.1 255.255.255.0
% Configuring IP routing on a LAN subinterface is only allowed if that
subinterface is already configured as part of an IEEE 802.10, IEEE 802.1Q,
or ISL vLAN.
R1(config-subif)#exit
R1(config)#exit
R1#
%SYS-5-CONFIG_I: Configured from console by console
R1#v
Pruebe la conectividad
*haga ping a la interfaz LAN/inalámbrica de WRS2
*en la PC3, haga clic en inicio ejecutar
*escriba cmd y seleccione abrir
*en el símbolo de sistema escriba ping (la dirección IP)
Haga ping a la PC1 y a la PC2 desde la PC3
*en el símbolo de sistema escriba ping (la dirección IP) para hacer ping a la
pc1
*repita en la dirección de la PC2
Borrar la configuración
*borre la configuración de WRS navegando a la página de Administration,
seleccione la ficha factory defaults y haga clic en el botón restore all settings