Documente Academic
Documente Profesional
Documente Cultură
TYPICAL PROPERTIES
Property Name
◆Preparation
Clean the surfaces by removing the rust, ash, and oil, etc.
◆Application
Pierce the opening with the tip of the cap. Fix the nozzle, and coat the surface evenly with the
adhesives, then assemble two parts.
◆Curing Condition
Put the surfaces in air to make it get full cure. The curing progress is from outer surface into
inner surface. The elastomer can get cure with the depth of 2~4mm in 24 hours (at room
temperature, 55% moisture), if the sections is too deep (especially the parts not easy to
contact with air) or the temperature is too low, the cure time will be extend.
Advise users preparing enough time to let elastomer get full cure in order to stable its
properties before the next disposing or packaging.
◆Attention
1. After the application, screw its nozzle tightly and store in dry and cool place for next time
using.
2. Some cured adhesives around the opening when you use it again, just remove the cured,
and use the uncured.
PACKAGING INFORMATION
80g/ tube, 300ml/tube.
NOTE
The data contained in this datasheet is of a general nature and is based on laboratory test condition.
Hengda does not warrant the data contained in this datasheet. Any warranty applicable to the product,
its application and use is strictly limited to that contained in Hengda's standard Condition of Sale.
Hengda does not assume responsibility for test or performance obtained by users. It is the user's
responsibility to determine the suitability for the product application and purpose and the suitability for
use in the users manufacturing conditions and methods. Hengda recommended that each user
adequately test its proposed use and application before repetitive use, using the data contained in this
sheet as a general guide.