Documente Academic
Documente Profesional
Documente Cultură
CONTENTS
This Test Project proposal consists of the following document/file:
SOAL-LKSJATENG2017.pdf
INTRODUCTION
The competition has a fixed start and finish time. You must decide how to best manage
your time.
Fa 0/0 25.10.21.200/23 -
ISP-Router
Se 0/1/0 24.10.20.17/29 2017:10:25:AAA::1/124
Fa 0/0 172.16.25.121/29 -
Lo 0 1.1.1.1/32 2017::1/128
Fa 0/0 172.16.25.122/29 -
Lo 0 2.2.2.2/32 2017::2/128
Lo 0 3.3.3.3/32 2017::3/128
Vlan1 172.16.25.123/29 -
Vlan10 10.10.10.1/28 -
Fa 0/1.100 x -
Fa 0/1.200 x -
Fa 0/1.1000 x -
Fa 0 25.10.20.17/22 -
Server-Internet
A1 Fa 0 DHCP
B1 Fa 0 DHCP
B2 Fa 0 DHCP
NB :
You don't have to configure Server-Internet and ISP-Router
X = ip address which you calculate by yourself
100 ROOM-A
200 ROOM-B
1000 IPPHONE
11. Configure the others switches except SW-GDG-MAIN so they can’t create, change,
or delete VLAN on their database.
12. Verify the VLAN database on ALL switches have same value.
1. Configure IPv4 Address and IPv6 Address of the CORE Routers Domain (CORE-R1,
CORE-R2, CORE-R3) with ip addresses as the table IP ADDRESS LIST in above.
2. Verify thath CORE-R3 can ping CORE-R1 and CORE-R2
3. Configure VLAN1 in Dist-SW can reacheable from CORE-R1 and CORE-R2 with an IP
address as the table above.
4. Configure DHCP Server service for ROOM A, ROOM B and IP PHONE in R-GDG, with
requiretments below:
Set DNS to local server in Server Farm
Calculate the VLSM according to hosts which needed following table
below!
Use the first IP address of the first subnet as gateway
Dont use IP address below, because is reserved for server soon
10 first IP address of range subnet 192.168.10.x/x is reserved
2 last IP address of range subnet 192.168.10.x/x is reserved
5 first IP address of range subnet 192.168.20.x/x is reserved
7 last IP address of range subnet 192.168.20.x/x is reserved
X is number of network, and use the first address as a gateway. In this case you can find out by
yourself!!
For Y on IPPHONE you can use the last address of the first subnet as gateway.
IPv4 ROUTING
1. Don’t CONFIGURE routing protocols on ISP-Router, Only devices store in local can use
this routing protocol.
2. Use routing protocol which can support unlimited hop count and allows scalability.
3. Configure the routing protocol’s identity for each router with the following
requirements:
hostname Identifier
CORE-R1 1001
CORE-R2 1002
CORE-R3 1003
Dist-SW 1000
R-GDG 1010
IPv6 ROUTING
1. Configure IPv6 routing protocol only for devices which have IPv6 address following
the IP ADDRESS LIST TABLE
2. Remember don’t CONFIGURE routing protocols on ISP-Router, Only devices store in
local can use this routing protocol.
PART 6 - HSRP
HSRP
1. Configure HSRP with grup 12 and use the highest one an IP address of the subnet for
the Virtual IP.
2. Set priority 50 for router with the lowest one mac address as a standby
3. Check MAC Address between two routers. The lowest mac address router use priority
50 and the highest use default.
3. Configure Remote Access Management Service which have encryption and configure
with following requirements:
a) Use default version of remote access
b) domain lksjateng2017
c) Generate a certificate file which is used to encrypt the packet with the highest
value.
d) Limit number of users who can connect to router for 3 users only.
e) All routers in Core Domain can access using remote access only.
DNS
DOMAIN IP ADDRESS
lksjateng2017.com 10.10.10.10
lkssmk2017.net 25.10.20.17
mail.lksjateng2017.com 10.10.10.11
www.lksjateng2017.com 10.10.10.10
www.lkssmk2017.net 25.10.20.17
FTP Server
Mail Server
USER PASSWORD
smk juara
tkj luarbiasa
Verify that PC in ROOM-A use “smk” user and ROOM-B use” tkj” user for sending email
successfully.
がんばってね