Documente Academic
Documente Profesional
Documente Cultură
Content
Content ......................................................................................................................................................... 2
1 Overview.................................................................................................................................................... 3
2 Features .................................................................................................................................................... 3
3 Specifications ............................................................................................................................................ 4
5 Appearance ............................................................................................................................................... 6
1 Overview
Based on long time Vehicle fuel sensor OEM experience and latest RF capacitor measurement &
computed tomography technology, the FS1000 fuel sensor can auto adjust gasoline, diesel , hydraulic
fluid or even water. Industry level design :leak resistant, waterproof, shock-resistant, vandal resistant and
high precision.
2 Features
1.The whole machine has no elastic parts and movable parts, which can withstand impact and easy
installation.
2.Adopt tomography technology, dynamically analyze various parameters of sensor in the medium,
3.No manual intervention, self-calibration, no temperature drift, and not affected by the medium.
4.Ultra-low power consumption, the whole machine power consumption is only 60mW, when 12V power
supply.
3 Specifications
Item Specifications
(5*30mm)
(8 meters)
5 Appearance
Flange
vent hole
Plug
Oil in hole
6 Wiring definitions
Notice:
1) FS1000 Fuel level sensor only supports one type of signal output. When Order it, need to
2)When connect fuel level sensor to GPS tracker’s RS232 port, its RXD wire connected to
tracker RS232 port’s TXD;TXD wire connected to tracker RS232 port’s RXD;
3) When connect fuel level sensor to GPS tracker’s RS485 port, its RS485 A wire connected to
7 Operation Guide
Clients need to measure the height of fuel tank, and tell Mobicom sales staff, will made the same length of
fuel sensor for you. Refer to below pictures, Get the fuel tank height(H) and Fuel sensor length(L):
Electric drill
or
Wire stripper
Silicone sealant
tracker
Note:
Drill the hole in the middle of the fuel tank to avoid that effect the accuracy when drive Vehicle Uphills
Drill the hole, Diameter is 28mm No need punch through, to avoid metal
Use the pliers to pick out the hole piece Drilling finished
Put rubber gasket on the hole, and coat with Insert the fuel sensor
Note:
Although FS1000 Fuel sensor can be self-calibration. But suggest clients tested the fuel sensor at office.
Connect the 8 meters connection cable , ‘MX3.0 2*2Pin’ plug to G200’s COM port; Another ‘AMP 4 Pin
Note:
To get the remaining fuel liters and fuel level percentage in fuel tank, User need to configure this vehicle’s
fuel tank volume in software platform. Refer to the document: < Web-based Monitoring Software
*SPJLX*P:753869*O:2,32,1,0,0,#
Connect the 8 meters connection cable , ‘MX3.0 2*2Pin’ plug to G500’s COM port; Another ‘AMP 4 Pin
Note:
To get the remaining fuel liters and fuel level percentage in fuel tank, User need to configure this vehicle’s
fuel tank volume in software platform. Refer to the document: < Web-based Monitoring Software
*SPJLX*P:753869*W:0,2,0,0#
*SPJLX*P:753869*W:0,0,0,2#