Documente Academic
Documente Profesional
Documente Cultură
Preparation
Be sure mirror are inspected after processing:
-To clean mirror with water and dry immediately after edge processing, especially around
mirror edges.
-Check the backpaint condition if there is any scratch of peel off around mirror edge
especially after edge processing, make sure the mirror used for the installation is clean
and dry, especially on the back paint and mirror edges.
Surface Preparation
-Wall surface must be cleaned and dry, never installed on new plaster, newly cured cement
or newly painted wall.
-If there is possibility that wall surface would have wet condition,
Apply water proofing layer on surface
-Poly plywood is commonly use as mounting surface, please noted that ;
Poly plywood need to be in dry condition-Oven pre heated plywood is preferable.
If poly plywood is attached to the wall using nail, after nailing, nail head must be
sealed using neutral sealant (to avoid direct contact with mirror back paint).
Mounting