Documente Academic
Documente Profesional
Documente Cultură
Sample Exam
These questions are similar to the problem sets found in the CSWP-SURF exam.
Note: You must use at least SolidWorks 2008 sp3.1 for this exam. Any use of a
previous version will result in the inability to open some of the testing files.
Question 1:
-Create a surface on the side using either Swept Surface or Surface Fill.
-The shape of the side surface should follow the contour of the "footprint" in the Sketch
Picture (found in Sketch123).
Create a curvature continuous fillet surface connecting the top and side surfaces
Fillet radius = 3 mm
-Create a 3 mm fillet that travels the full length between the top and side surfaces.
What is the surface area of the fillet (in mm^2)? (within +/- 10 mm^2)
A) 322.50
B) 348.10
C) 374.10
D) 399.30
Question 3:
-Trim the surfaces at the end of the mouse at an angle of 5 degrees while keeping the
length of the mouse as shown in the image.
Top surface
-Mirror the existing surfaces and complete the steps to create the solid of the completed
part
ADVICE
You should be able to answer all four questions correctly within 20 to 30 minutes
Read through every question first. This will help you save time and make correct
decisions when choosing how to proceed.