Documente Academic
Documente Profesional
Documente Cultură
TABLE OF CONTENTS
1 GENERAL 3
1.1 SCOPE 3
1.2 UNITS OF MEASUREMENT 3
1.3 CODES AND PROJECT REFERENCE DOCUMENTS 3
1.4 MATERIAL PROPERTIES 3
1.5 DESIGN LOAD CASES 4
1.6 SERVICEABILITY REQUIREMENTS 5
1.7 STRENGTH DESIGN CONDITION 6
1 GENERAL
1.1 SCOPE
This document is the design specification for the proposed Warehouse located at State of São Paulo, Brazil
1.2 UNITS OF MEASUREMENT
Units of measurements used in analysis shall be of SI Units.
5) Purlins and Girts American Standard ASTM A653 SS Grade 50 (Yield Strength,
Fy = 345 Mpa). Galvanized Cold Formed Z Shape with Lips
6) Brace Rods / Sag Rods American Standard ASTM A36 Steel (Yield Strength, Fy = 248
Mpa) or GB Q235 or equivalent
Seismic Load (E) : Zone 0 (No Seismic Provision) per Figure Below
Load Combinations (For Allowble Stress Design) per section 2.4.1 of ASCE 7-05
: D + L (Permanent Case)
: D + 0.75L + 0.75Lr (Permanent Case)
: 0.60D + 1.0 W (Temporary Case with Wind)
: 1.0D + 1.0 W (Temporary Case with Wind)
: 1.0D + 0.75L + 0.75Lr + 0.75W (Temporary Case with Wind)
1.6 SERVICEABILITY REQUIREMENTS