Documente Academic
Documente Profesional
Documente Cultură
PHYSICS TEST
AC CIRCUITS
1. The voltage of an ac supply varies with time (t ) as V 120 sin 100 t cos 100 t. the maximum
voltage and frequency respectively are
120
A) 120 volts, 100 Hz B) volts, 100 Hz
2
C) 60 volts, 200 Hz D) 60 volts, 100 Hz
2. In the circuit shown in the figure, the ac source gives a voltage V 20 cos( 2000 t).
Neglecting source resistance, the voltmeter and ammeter reading 6
A
will be 5mH 4 50 F
A) 0V, 0.47A B) 1.68V, 0.47A
C) 0V, 1.4 A D) 5.6V, 1.4 A V
3. A telephone wire of length 200 km has a capacitance of 0.014 F
per km. If it carries an ac of frequency 5 kHz, what should be the value of an inductor
required to be connected in series so that the impedance of the circuit is minimum
A) 0.35 mH B) 35 mH C) 3.5 mH D) Zero
4. Instantaneous current in branch having capacitor C will be:
A) 20 2 sin t 3 / 4 B) 40 2 sin t / 4
C) 60 2 sin t / 4 D) None of above
5. In the above problem, angle between current through inductor and capacitor will be
A) 143° B) 90° C) 53° D) None
6. In the above problem, potential drop across XL by a.c. voltmeter will be
A) 160 volt B) 120 volt C) 200 volt D) 160 2 volt
7. The r.m.s. current in an ac circuit is 2 A. If the wattless current be 3 A , what is the
power factor?
1 1 1 1
A) B) C) D)
3 2 2 3
8. A bulb and a capacitor are in series with an ac source. On increasing frequency how
will glow of the bulb change
A) The glow decreases B) The glow increases
C) The glow remain the same D) The bulb quenches
Page 1
AC Circuits Ranker
10. For a series RLC circuit R = XL = 2XC. The impedance of the circuit and phase
difference (between) V and i will be
5R 5R 1 1
A) , tan 1 (2) B) , tan 1 C) 5 X C , tan 1
(2 ) D) 5 R, tan 1
2 2 2 2
11. In the adjoining ac circuit the voltmeter whose reading will be zero at resonance is
A) V1 B) V2 V 4
C) V3 D) V4
V1 V2 V3
L C R
V5
Page 2
AC Circuits Ranker
17. In figure below if ZL Zc and reading of ammeter is 1 A. Find value of source voltage
V.
A) 80 Volt B) 60 Volt
C) 100 Volt D) None of these
18. In the circuit given below, what will be the reading of the voltmeter?
A) 300 V B) 900 V V 100V 100V
C) 200 V D) 400 V
200V, 100 Hz
A) 800 V, 2A
B) 300 V, 2A A V
C) 220 V, 2.2 A 300 V 300 V
D) 100 V, 2A 220 V, 50 Hz
20. A bulb and a capacitor are connected in series to a source of alternating current. If its
frequency is increased, while keeping the voltage of the source constant, then
A) Bulb will give more intense light
B) Bulb will give less intense light
C) Bulb will give light of same intensity as before
D) Bulb will stop radiating light
21. An alternating e.m.f. of angular frequency is applied across an inductance. The
instantaneous power developed in the circuit has an angular frequency
A) B) C) D) 2
4 2
22. The graph of alternating current versus time is shown in figure. The average value for
the positive half cycle, is
I
A) 0 B) 2I 0
3
C) 5I 0 D) I 0
8 2
23. As shown in figure value of inductive reactance XL will be if source voltage is 100 volt
A) 40
B) 30
C) 50
D) Can have any value
24. In the series LCR circuit, the voltmeter and ammeter readings are
respectively:
A) V = 250V, I = 4 A
B) V = 150V, I = 2 A
C) V = 1000V, I = 5 A
D) V = 100V, I = 2 A
Page 3
AC Circuits Ranker
25. Following figure shows an ac generator connected to a "black box" through a pair of
terminals. The box contains possible R, L, C or their combination, whose elements and
arrangements are not known to us. Measurements outside the box reveals that e = 75
sin t volt, i = 1.5 sin ( t + 45o) amp then, the wrong statement is
A) There must be a capacitor in the box
B) There must be an inductor in the box
?
C) There must be a resistance in the box
D) The power factor is 0.707
26. A given LCR series circuit satisfies the condition for resonance with a given AC source.
If the angular frequency of the AC source is increased by 100% then in order to
establish resonance, without changing the value of inductance, the capacitance must be
A) Increased by 100% B) Reduced by 50%
C) Increased by 75% D) reduced by 75%
2 .5
F Capacitor and 3000-ohm resistance are joined in series to an ac source of 200 volt
27.
and 50 sec 1 frequency. The power factor of the circuit and the power dissipated in it
will respectively
A) 0.6, 0.06 W B) 0.06, 0.6 W C) 0.6, 4.8 W D) 4.8, 0.6 W
28. The self inductance of a choke coil is 10 mH. When it is connected with a 10V dc
source, then the loss of power is 20 watt. When it is connected with 10 volt ac source
loss of power is 10 watt. The frequency of ac source will be
A) 50 Hz B) 60 Hz C) 80 Hz D) 100 Hz
29. In an LCR circuit R 100 ohm. When capacitance C is removed, the current lags behind
the voltage by / 3 . When inductance L is removed, the current leads the voltage by / 3 .
The impedance of the circuit is
A) 50 ohm B) 100 ohm C) 200 ohm D) 400 ohm
30. In the circuit shown in figure neglecting source resistance the voltmeter and ammeter
reading will respectively be V
A) 0V, 3A
R = 30 XL = 25 XC = 25
B) 150V, 3A A
240 V
C) 150V, 6A
D) 0V, 8A
Page 4
AC Circuits Ranker
KEY
1. D
2. D
3. A
4. A
5. A
6. D
7. C
8. B
9. B
10. B
11. D
12. C
13. A
14. D
15. A
16. C
17. C
18. C
19. C
20. A
21. D
22. D
23. C
24. D
25. B
26. D
27. C
28. C
29. B
30. D
Page 5
AC Circuits Ranker
SOLUTIONS
1. D
V 120 sin 100 t cos 100 t V 60 sin 200t
Vmax 60 V And 100Hz
2. D
Z (R)2 (X L X C )2 ;
3
R 10 , X L L 2000 5 10 10
1 1
XC 6
10 i.e . Z 10
C 2000 50 10
V0 20
Maximum current i0 2A
Z 10
2
Hence irms 1. 4 A and Vrms 4 1 . 41 5.64 V
2
3. A
Capacitance of wire
C 0 . 014 10 6 200 2 . 8 10 6 F 2 . 8 F
For impedance of the circuit to be minimum X L XC 2 L
1
2 C
1 1
L
4 C 4(3.14) (5 10 3 )2 2.8 10 6
2 2 2
0 . 35 10 3 H 0 . 35 mH
4. A
Current leads in capacitor by 900
5. A
90+Tan-1(4/3).
6. D
7. C
3
iWL irms sin 3 2 sin sin
2
60 o
so p.f. cos cos 60 o
1 .
2
8. B
This is because, when frequency is increased, the capacitive reactance XC
1
2 C
decreases and hence the current through the bulb increases
9. B
P 240
R 2
15
irms 16
V 100
Z 25
i 4
Page 6
AC Circuits Ranker
R2 5
Also Z R 2 (X L X C )2 R2 R
4 2
11. D
At resonance net voltage across L and C is zero
12. C
Given X L X C 5, this is the condition of resonance. So VL VC , so net voltage across L
and C combination will be zero.
13. A
At angular frequency, the current in RC circuit is given by
Vrms
irms ...... (i)
2
1
R2
C
irms Vrms Vrms
Also ...... (ii)
2 2 9
2
R 2 2
1 C
R2
C
3
From equation (i) and (ii) we get
1
5 3 XC 3
3R 2 2 C
2
C R 5 R 5
14. D
XL XC o XL XC
tan tan 60
R R R R
X L X C 3 R
i.e. Z R 2 (X L X C )2 R
V 2 200 200
So average power P = 400 W
R 100
15. A
For dc, V 100
R 100
i 1
L 0 . 55 H
E0 i0 R
16. P Erms irms cos
2 2 Z
E0 E0 R E2R
P 02
2 Z 2 Z 2Z
E02
Given XL R so, Z 2 R P
4R
17. C
If ZL ZC current will be same,
So, VZ VZ ; L C
Page 7
AC Circuits Ranker
1
VL 1 2 30 60 Volt
VR 80 1 80volt ; V VL2 VR2 80 2 60 2 100 Volt
18. V 2 VR2 (VL VC )2
10 V VL
i
100V, 50Hz
Also 220
i 2 .2 A
100
20. When a bulb and a capacitor are connected in series to an ac source, then on increasing
the frequency the current in the circuit is increased, because the impedance of the
circuit is decreased. So the bulb will give more intense light.
21. The instantaneous values of emf and current in inductive circuit are given by
E E 0 sin t and i i0 sin t respectively.
2
So, Pinst Ei E0 sin t i0 sint
2
E0 i0 sin t sin t cos cos t sin
2 2
E 0 i0 sin t cos t
1 (sin 2t 2 sint cos t)
E 0 i0 sin 2 t
2
I.dt I
Iavg 0
T/2 0
2
dt
0
23. C
2 2
VI 20 10
X L X L X C2
2 2
100 2 30 30 XL 40
2 2 2
50 30 X L 10
2
X L 10 80 20 ; XL 10 40 ; XL 50
24. D
V = VR + (VL – VC)
100 = VR + (200 – 200)
VR = 100V
Page 8
AC Circuits Ranker
100
i 2
50
25. B
1
26. L = (for resonance)
c
1
2 . . . (i)
LC
for case (ii)
1
2 2 . . . (ii)
LC1
C C
(ii) divide (i) 4 = C1 .
C1 4
The capacitance is to be reduced by 75%.
Z (3000)2 (4000)2 5 103
2
27. Z
1
R2 (3000 )2
1
2
2C 2 .5
2 50 10 6
2
R 3000 Vrms cos (200)2 0.6
So power factor cos 0.6 and power P Vrmsirms cos P 4.8W
Z 5 103 Z 5 103
V2 (10 ) 2
28. With dc: P R 5 ;
R 20
2
Vrms R (10 ) 2 5
With ac: P Z2 50 2
Z2 10
Also Z 2 R 2 4 2 2 L2
50 (5)2 4 (3 .14 )2 2 (10 10 3 )2 80 Hz.
X
29. When C is removed circuit becomes RL circuit hence tan L .....(i)
3 R
X
When L is removed circuit becomes RC circuit hence tan C .....(ii)
3 R
From equation (i) and (ii) we obtain XL = XC. This is the condition of resonance and in
resonance Z = R = 100
30. D
The voltage V L and VC are equal and opposite so voltmeter reading will be zero.
Also R 30 , X L X C 25
So i V V 240
8A
R 2 (X L X C )2 R 30
Page 9