= - ci DOI sia ae re
THE
“cherokee CRUISER
and FLITE LINER
=
PILOT'S OPERATING MANUAL,
a eee stceiem
peter ers em epee
airy
anWARNING.
[EXTREME CARE MUST DE EXERCISED TO LIMIT THE USE OF THIS MANUAL
‘TO APPLICABLE AIRCRAFT. THIS MANUAL REVISED AS INDICATED BELOW
(OK SUBSEQUENTLY REVISED 15 VALID FOR USE WITH THE AIRPLANE
IDENTIFIED BELOW WHEN APPROVED BY PIPER AIRCRAFT CORPORATION,
SUBSEQUENT REVISIONS SUPPLIED BY PIPER AIRCRAFT CORPORATION
[MUST BE PROPERLY INSERTED.
MODELPA.28-140,
AIRCRAFT SERIAL NO, —_28:7625087_ REGISTRATION NO. 48820
PILOT'S OPERATING MANUAL, PART NUMBER 761 555 REVISION 7-18-75
PIPER AIRCRAFT CORPORATION
[APPROVAL SIGNATURE AND STAMP. eked,
Assurance tht the seplane sin an arworthy condition isthe responsblity of the owner
‘The plot in command is responsible for determining thatthe airplane iste for fight. The plot
iz alo responsible for remaining within te operating limitations outlined by the Aisyiane Flight
Manoa; iatuinent warhigs, amd placasds
‘This Plot's Operating Manual is not designed as a substitute for adequate and competent
Aight instruction, knowledge of the curent aurworthiness directives, applicable federal air
regulations, or advisory ciralas It not intended to bea gue for baie Mght instruction ofa
{raining manual for wansitio from single to multiengine fying
Ian inconsisteney of information exists between the Plot's Operating Manual and the
Auplane Flight Manual approved by Ue FAA, Une Auplase Fight Manual shall be the
authonity
A, complete or sartial replacement of this manual, Part No
"761555, may be cbtained only from Piper Customer Service,
Published by
PUBLICATIONS DEPARTMENT
Piper Aircraft Corporation
761 355,
Issued: July 1973
A5 ae
APPLICABILITY
‘This manual is applicable to Piper Model PA.78-140 aircraft having serial numbers
‘commencing with 28742500]. The concluding limit to applicable serial numbers was not
‘availabe at time of printing. Contact Piper Customer Services (or specifi information on the
‘pplication ofthis men
REVISIONS,
‘The information compiled ia the Pilot's Operating Manual wil be kept current by revisions
‘striated tothe aiplane owners
Revision material will consist of information necessry Lo update the text of the present
‘anual andjor toad information to cower added airplane equipment
Revisions
Revisions will be distributed whenever necessary as complete page replacements oF
‘additons and shal be inserted into the manual in accordance with the instructions given below
Revision pages will eplce only puges with the same page number
Ince all additional pages in proper aumerical order within each section
Page numbers followed by a small Iter shall be inserted in direct sequence withthe
‘ume common numbered Pate,
1, deniiason of Revised Materia
Revised text and ilstations shall be indicated by a black vertical line along the left hand
surg of tho page, opposite revised, added or deleted material. A line opposite the page
‘ume ‘or sceton tile and printing date wil indicat that the text of lustation Was
tinchanged but materidl wus relocated to «different page or that an entire page was added,
Black: ines will indicate only current revisions with changes and additions to or deletions
‘of existing text andilstations. Changes in eaptalization, speling, punctuation or the physical
Toeaton of materia on s page wll not be sented by symbol.
HL, Original Pages sued
‘The orginal pages issued for this manval prior to revision are given below:
ot through 1-4, 24 through 2-18, 3:1 through 3:18, 4-1 thxough 46, 5-1 through $32,
7-1 trough 711, 84 through 8-2, 9+ through 9-11, 10-1 through 10-15,