Documente Academic
Documente Profesional
Documente Cultură
340
324 Padlocking configuration
Control by an external
Caution: Ensure that the product is installed on a flat rigid surface. 116
350
143
245
45
terminal Operation
connections MAX : 2
340
Preliminary operations Tighten to avoid 326
DIN RAIL "
#
#
$& 52 104 176
Check the following upon delivery and after removal of the IEC 60715
packaging:
n Packaging and contents are in good condition.
n The product reference corresponds to the order.
n Contents should include:
Posidriv PZ2
Qty 1 x ATyS M
131,5
131,5
47
Qty 1 x Emergency handle extension rod
Qty 1 x Set of terminals
Quick Start instruction sheet To allow padlocking in all
positions (I - O - II), configure
!
Warning Posidriv PZ1 6 mounting brackets installation. (Screw is located
1 Nm 6x M6 screw - 2,5 Nm at the back of the product).
Risk of electrocution, burns or injury to persons and /
or damage to equipment. STEP 1
This Quick Start is intended for personnel trained in the *
'
"
;<=?@2 connections. !
installation and commissioning of this product. For further STEP 2 Power Terminal Connections They can be fitted in any terminals on the source
details refer to the product instruction manual available on supply side. Do not use on the load side when
the SOCOMEC website. equipped with a bridging bar.
It is essential to tighten Load side Posidriv PZ2
n This product must always be installed and commissioned
###' bridging bar. 2x
by qualified and approved personnel.
#
!
#'
125A: 1309 4006
n Maintenance and servicing operations should be 2
performed by trained and authorised personnel. 160A: 1309 4016 Posidriv PZ2
22 24 21 22 24 21
5: Power supply II (230 VAC)
order 0 Auxiliary contacts: One module factory fitted (1309 0001). 6: Voltage tap
STEP 5C Padlocking mode
order II Fitting of the 2nd AC: 1309 0001 or 1309 0011 7: Auxiliary contact block -
To fit an AC, the switch must first be put in position 0. An auxiliary contact module comprises: 1 NO/NC contact per position I,
7 0, II (1x factory fitted )
In order to padlock put the position I one NO/NC changeover contact for each position (I-0-II). To install use the long screws supplied 11 14 12 11 14 12
www.socomec.com/en/atys-d-m 1 3 C
To download, brochures, catalogues and technical manuals. 2
Use 35mm
For contactor logic bridge screws for 5
Printing informations: 1 color Black. White paper 90g/m2. 2 modules
Printing size: 420x297. Final size 210x297. This page visible first. contact 313 with 317. 4 * Remote orders from ATS
A separate sheet for each language. controller such as ATyS C20/
To operate: close the Pozidriv PZ2 - 1 Nm C30/C40 or PLC, BMS, etc.
contact corresponding to
1x 4-8 mm the desired position.
Non contractual document.
542 928 B - 06/14 - EN Subject to change without notice.