Documente Academic
Documente Profesional
Documente Cultură
1 : Viewfinder/lens
2 : Universal attachment
3 : Attaching screw
4 : Nut
5 : Handlebar attachment
6 : Helmet attachment
7 : Waterproofing O-ring
8 : USB Cable
9 : Audio-Video Cable
10 : Self adhesive rubber
11 : Velcro pad
12 : Short velcro pad
13 : Long velcro pad
14 : Silicon helmet clamping strip
15 : Nut
16 : Silicon grease pot for O-ring
17 : LCD screen
18 : ON/OFF and ENTER button
19 : Start/stop video button
20 : Menu button
21 : Microphone
22 : USB Connector
23 : Audio/video connector
24 : SD Cable
25 : SD Card (not supplied)
26 : Battery cover
27 : Batteries
12
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 13
Congratulations on buying the X-Snipe 300 sport video camera. This product will be your
companion in your leisure activities, your sports activities or, simply, your everyday life.
EN Resistant, waterproof, practical, you will be delighted by its versatility and its many useful
applications.
LIMITED WARRANTY
EN
DECATHLON guarantees the initial purchaser that this camera is free from defects of materials or
manufacture for a period of two years from the date of purchase. Please keep your receipt as proof
of purchase.
• The guarantee does not cover damage caused by misuse, a failure to observe the precautions for
use or accidents, or incorrect maintenance or commercial use of the apparatus.
• This warranty does not cover damage resulting from repairs carried out by persons not authorised
by DECATHLON.
• The guarantees contained herein explicitly override all other guarantees including the standard
guarantee of merchantability and/or suitability for use. DECATHLON may not in any circumstances
be held liable for any direct or indirect damage, whether general or specific, caused by or in connection
with these instructions for use or the products which they describe.
• During the warranty period, the item will either be repaired free of charge by an authorized repair
service or replaced free of charge (depending on the distributor).
• The warranty does not cover batteries or cracked or broken casings where signs of a blow
are evident.
RESTRICTIONS IN USE
Precautions for use :
Waterproof design:This product is resistant to water splashes. It does not, however, respond well
to cleaning in open sea or deliberate subjection to underwater conditions. It is NOT, for example,
designed for underwater photography.
• Handle the product with care - do not drop it or subject it to strong impacts.
• For improved safety, avoid turning the knobs while in action. Failure to concentrate could
be dangerous.
• Do not take the product apart. This would void the warranty and could cause damage and loss
of waterproofing.
13
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 14
• Read the instructions carefully before use.Keep the instructions for the entire life of the product.
• Do not subject the camera to extreme temperatures.
• Only use a soft, damp cloth or an aerosol spray to clean the product. Do not use detergents, as
they could damage the materials. Do not rub the lens with instruments which might cause
scratches.
• Do not forget to switch off the apparatus before taking out the batteries and SD card. The data you
have recorded could be damaged.
• Take out the batteries and the card before leaving the apparatus unused for a long period.
• Use in a cold atmosphere will require the use of batteries which can stand up well to low
temperatures Use where possible lithium or NiMH rechargeable batteries, as alkaline batteries
and especially saline batteries function very badly in low temperatures.
I Limited liability:
• Geonaute accepts no liability for accidents and injuries caused by the handling or use of the
camera in high risk sports. In particular, Geonaute wishes to warn the user of possible defocusing
as the result of inappropriate detachment or handling in dangerous conditions.
• The user is warned that he bears full legal responsibility for photographs taken with the X-Snipe
300 and their distribution and publication.
4 Replace the battery cover and firmly close the rear plastic cover
N.B. Change your video sequences in the PC before proceeding to replace the batteries.
Otherwise you risk losing the data.
When the batteries are nearly empty, the “battery” sign will appear on the LCD screen. It is then time
to download the videos on the PC and to replace the battery.
Note : Replace both batteries at the same time, do not mix old batteries with new ones.
Do not mix alkaline batteries with rechargeable batteries. The USB cable cannot charge
rechargeable battteries inside the camera. They must be separately recharged by an external
charger
14
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 15
The “crossed-out bin” symbol indicates that this product and the batteries it contains
cannot be disposed of with household waste. They are subject to a specific type of
sorting. Take the batteries and your unusable electronic product to an authorised
collection area for recycling. This treatment of your electronic waste will protect the
environment and your health.
FIRST USE
EN
Setting up the camera
The camera can be assembled in different ways using the various combinations of straps and
velcro provided in the pack. We would suggest the following setting up procedures.
15
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 16
After inserting the batteries, the camera is ready to function. Now press on the "go/stop" button for
2 seconds until you hear a double bleep. The LCD screen will light up.
To switch off the camera after use, repeat the same operation :
Keep the "go/stop" button pressed down for 2 seconds.
The LCD screen will switch off.
Note : if the camera is connected to the PC, you will have to disconnect it
from the PC to turn it off.
N.B: Make sure that the X-Snipe is switched off before carrying out this operation.
You could damage the card and the data. Do not touch the connectors of the SD card.
You can use on the X-Snipe 300 SD format memory cards with a capacity varying from 8MB to 2
GB.
16
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 17
5 The available film time left on the SD card will then appear. If the Error symbol is shown, switch
off the camera, remove the SD card and check that the card is not code protected and that it is in
good condition.
EN
Remove it carefully from its casing.
4 Replace the plastic cap.
Shooting
NB: As with any video camera, the stability of the cameraman is a key feature in the success of the
film. Be careful not to move too much, not to move too quickly, not to film objects which are too
close or too far away, or to change too quickly from distance to close focus.
The focus distance is from 1.5 metres to infinity.
2 Press on the video shutter release to begin recording (1 beep); the time which has elapsed for that
sequence will be shown on the LCD screen.
3 Press again on the video filming button (2 beeps). The length of the sequence filmed in this way
will be shown for 3 seconds on the screen. After this the time of filming remaining on the DS card
will be shown as a permanent feature.
Connecting to a PC :
This camera needs the following minimum system to operate :
Pentium III 800Mhz or more - Windows XP or Windows 2000 - 128 MB RAM - 800 MB of free hard
drive - A minimum resolution SVGA (800*600) - a 16 bits sound interface
1 Switch on the sportscam X-snipe 300
2 Connect the camera to the PC using the USB cable delivered with
the Pack
3 The symbol "PC" appears on the LCD screen of the X-Snipe 300
4 The X-Snipe 300 creates a detachable disk like any other USB
key in the “work station”. If you are connecting the X-Snipe to
a PC for the first time, the USB pilot will install itself
automatically. Respond positively to messages inviting
installation.
17
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 18
5 Format video files. AVI are included in the attached directory: You may immediately copy them into
the hard disk directory of your choice before removing them to free up space on your card
Connection to a television:
1 Connect the X-snipe 300 to your television using the Video cable
and paying attention to the colour of the pictures.
2 The symbol "AU" appears on the LCD screen of the X-Snipe 300
and the television mode will be automatically activated.
3 The function keys then appear on the television screen :
Pause, Stop, go back, read, fast forward, delete.
4 To use those commands: Press on the «MENU» button of the camera in order to select one or
other of the functions, then press «ENTER» in order to validate the function selected.
5 To delete a video, use the «delete» function and then confirm by pressing on the ENTER button
18
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 19
The higher the resolution, the better the picture quality or the bigger the picture, the more storage
EN
space it has.
The maximum length of recording therefore depends on the resolution chosen.
The folowing table shows the approximate recording times on different SD card capacities.
Sound recording
When the «sound» icon is flashing, the «ON» option will be shown on the LCD screen. This means
that the background noise will be recorded during the filming.
Press on the recording button to change the adjustment to «OFF» and thus cut off the sound
recording.
Confirm the setting chosen by pressing on ENTER (the validation is confirmed by a double beep.)
I N.B. the X-Snipe 300 microphone has splash protection. It is intended for recording
background noise and not a directional sound (voice). The sound volume, because of the
waterproofing of the product, will be too weak to record a conversation.
19
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 20
Deleting videos
You have the option of deleting the videos made direct from the camera. To delete the last video
made, press on the MENU button as many times as necessary to turn on the icon . Confirm by
pressing on ENTER.
Repeat those operations to delete several videos.
To delete all videos at once, press on the MENU button as many times as is required to obtain the
icon . Confirm by pressing on ENTER
Note: It could take several minutes to delete all the videos if there has been a lot of recording.
This equipment has been tested and certified as complying with the limits of Class B numerical
apparatus, under the provisions of Section 15 of the FCC. Those limitations are imposed to ensure
reasonable protection against intrusive interference within a residential installation. This equipment
generates, uses and emits radio energy frequencies and, if it has not been installed in accordance
with the instructions, could provoke harmful interference to radio communications. However, there
is no guarantee that it will produce no interference in any particular installation. If this equipment
provokes intrusive interference with radio or television reception, interference which can be
ascertained by the camera off and then switching it on again, it is recommended that the user take
one of the following measures to remedy such interferences:
- Reorientate or move the reception antenna.
- Increase the distance between the apparatus and the receiver.
- Link the equipment to a power supply on a circuit other than the one to which the receiver is
linked.
- Seek advice from the vendor or from a radio/television technician.
20
2-10732 - X Snipe - FR-ENp4-21:Notice - 10732 X Snipe 25/07/07 14:43 Page 21
I N.B. Any change or modification which has not been expressly authorised by Décathlon is
liable to delete the authorisation granted to the user for the use of the equipment.
CONTACT
So that we continue to develop improved products which meet your needs, we are pleased to hear
EN
your feedback with regard to the quality, functionality and usage of our products.
21