Documente Academic
Documente Profesional
Documente Cultură
2/ Check that the correct machine serial number is written in ‘machine setting’.
6/ Put the switch on the power supply card PS407 on ‘off’ position
8/Wait 10 seconds
11/ Put the switch on the power supply card PS407 on ‘ON’ position. Wait 5 seconds
13/ Hold the switch on the ‘MRES’ position until the ‘STOP’ LED blinked twice. Release the switch (which goes back to
the stop position) and hold it back to the ‘MRES’ position within the second! The ‘STOP’ LED might blink quickly. When
the LED stop to blink, release the switch. If this step is not done correctly, start back to the step 12/.
14/ Put the switch on the power supply card PS407 on ‘OFF’ position.
16/ Put the switch on the power supply card PS407 on ‘ON’ position. Wait 5 seconds.
17/ Put the CPU switch on ‘RUN’ position. After a few seconds, check that all the LED on the CPU and the power supply
card PS407 are green. If any LED remain not green (fault LED or ‘STOP’ LED still on for example), put the CPU switch on
‘STOP’ and back on ‘RUN’ once again.
18/ Check that the communication with the PCC is still working, check that the machine number is correctly set in the
machine setting. If the communication doesn’t work, restart the PCC application.
19/ In the PCC main page, in the fault frame, you might find the message ‘machine preconfiguration successful’ (to learn
more about preconfiguration, do not hesitate to consult the technical sheet #112, the SIDEL technical assistance can
provide you this sheet).
///////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////
2 / Compruebe que el número de serie de la máquina correcta está escrita en "configuración de la máquina".
8/Wait 10 segundos
11 / Ponga el interruptor en la tarjeta de fuente de alimentación PS407 en la posición 'ON'. Espere 5 segundos
13 / Mantenga el interruptor en la posición de los 'MRES' hasta el 'STOP' LED parpadeó dos veces. Suelte el interruptor
(que se remonta a la posición de parada) y lo hace retornar a la posición de los MRES », en el segundo! La palabra
"STOP" LED puede parpadear rápidamente. Cuando la parada del parpadeo del LED, suelte el interruptor. Si este paso no
se realiza correctamente, comience de nuevo el paso / 12.
16 / Ponga el interruptor en la tarjeta de fuente de alimentación PS407 en la posición 'ON'. Espere 5 segundos.
17 / Ponga el interruptor de la CPU en posición 'RUN'. Después de unos segundos, compruebe que todos los LED de la
CPU y los PS407 alimentación de la tarjeta son de color verde. Si alguno no permanece LED verde (LED de fallo o 'STOP'
LED todavía en, por ejemplo), poner el interruptor de la CPU en "STOP" y de vuelta en 'Run', una vez más.
18 / Comprobar que la comunicación con el PCC sigue trabajando, compruebe que el número de la máquina está bien
configurada en la configuración de la máquina. Si la comunicación no funciona, reinicie la aplicación del PCC.
19 / En la página principal del PCC, en el marco de culpa, usted puede encontrar el mensaje de 'máquina de éxito de
preconfiguración (para conocer más acerca de preconfiguración, no dude en consultar la ficha técnica # 112, la
asistencia técnica SIDEL le puede proporcionar esta hoja ).