Documente Academic
Documente Profesional
Documente Cultură
i. Set auto to semi auto and wait for completion of next cycle OR
ii. Shut off material to barrel
iii. Let auto empty barrel of material [34 samples to purge full barrel]
iv. Alarm sounds due to time out on auto cycle (reset machine)
v. Open mold manually
vi. Eject part fully from mold
vii. Close mold manually but not at high pressure (check pressure gauge reading is zero)
viii. Move nozzle RHS
ix. Inject material out of barrel
x. OM – return screw
xi. Inject material fwd and backward
xii. OM – return
xiii. Inject fwd and bwd
xiv. Screw fwd
xv. Inject fwd and bwd
xvi. Stop pump
xvii. Turn off machine and chiller
1st pressure setting fills 90+% cavity and related to speed of screw
E stop on machine
If purge plastic does not clean barrel then remove barrel from machine and clean {see Manual pg
4-16}
Operate at slow speed for first 5,000 cycles before increase speed
MENU>
ADJ> MOLD > Decomp Tm (mold decompression time) 0.5
Mold Cls St Tm (mold closing start time) 0.25
Hi Prs Chg St Tm (High pressure select start timing) 0.25
NOZZLE> Cl Nzl Incr Prs Tm (injection unit pressure increase time) 0.2
Nzl Bwd St Tm (start of injection unit backward time) 0.1
Nzl Bwd Tm (injection unit backward time) 0.0
Tensile sample 1.04g per shot Barrel capacity 5.5 g per shot
Injection Panel
1. Low pressure close [V3] x = 11.1mm (fixed nut to knurled boss)
2. Injection 1st pressure [V18] x = 10.0mm
3. Injection 2nd pressure [V19] x = 10.5mm
196.0
144.0
112.5
Machi
48.5 ne
frame
115.0
00
132.0
400 + 150
Regrinding Machine
Material PP