Documente Academic
Documente Profesional
Documente Cultură
Disassembly/reassembly
bizhub C3110 procedure (b...
[1]
[1] [2]
[1]
[2] [3]
8. Install the new MFP board.
9. Install the removed SSD board on the new MFP board.
10. Connect the MFP board to the disconnected connectors and flat cables.
Install the four removed wire saddles.
11. Turn ON the power switch.
NOTE
• Do not perform any printing operation at this stage.
G-9
G DISASSEMBLING/REASSEMBLING > 3. Disassembly/reassembly
bizhub C3110 procedure (b...
14. Turn OFF the power switch.
15. Remove the new EEPROM [1] from the MFP board, and mount the
[1] old EEPROM [2] that is located on the old MFP board.
[1]
[2]
NOTE
A
• When mounting EEPROM (IC15), make sure the notches
("A") are precisely lined up.
CAUTION
• If the service call: D093 (wrong hard disk) occurs continuously
even when the above procedures have been performed, format the
hard disk in accordance with the following procedures.
G-10